2020 Ford Expedition: what breaks, and at what mileage

What owners report breaking

Owners have reported 67 named failure modes on the 2020 Ford Expedition, and the three most-reported carry 42% of everything filed.

Other powertrain problem leads with 151 reports, about 1.9 per 1,000 vehicles and with the middle half of reports between 40k to 87,500 miles.

Other engine problem follows with 42 reports, usually reported between 28k to 100,000 miles. 2 of those reports mention a fire.

Other electrical problem follows with 25 reports, median 105,000 miles. 3 of those reports mention a fire.

By system, the reports fall mostly into transmission (205), engine (64) and electrical (48).

How bad it is when it goes

Across the named modes, 7 mention a crash, 11 a fire and 19 an injury. Those are the words owners used in their own complaints, and NHTSA does not verify them, but they are the closest thing in this data to a measure of what a failure actually did.

The average severity weight across every report on this year is 4.35, where a stalled engine or a failed airbag weighs many times more than a rattling trim panel, and a figure this high means the reports are dominated by failures with safety consequences rather than annoyances. The weighting is set out in full on the methodology page.

What the top failures cost to put right, as editorial estimates for an independent US shop rather than figures from NHTSA: other powertrain problem at $400–$4,500, other engine problem at $300–$4,000, other electrical problem at $250–$2,000 and complete transmission failure at $2,800–$8,000. Dealer labour, a seized bolt or a part that is no longer made can push any of these past the top of its range.

54% of the reports on this year sit in the engine, transmission, drivetrain or cooling systems — the four where a repair bill is usually four figures, so more than half of what owners complained about here is expensive.

How often, against how many were built

Scaled by an estimate of how many of these cars exist, the 2020 Ford Expedition draws about 6.7 per 1,000 vehicles, which puts it in the 87th percentile of complaint rates among 2020 vehicles we can rate.

That denominator is the weakest number on the page and it is fair to say so plainly. Rate per 1,000 uses a fleet-size estimate derived from recall paperwork for this exact model year. It is a lower bound.

The working figure is 78,351 vehicles. If the true number is twice that, every rate on this page is half what it says; the ranking against other 2020 vehicles, which is what the risk score uses, is far more robust than the rate itself.

Recalls on the 2020 model year

NHTSA has issued 18 recall campaigns covering the 2020 Ford Expedition, affecting an estimated 386,879 vehicles. A recall is a different kind of evidence from a complaint: it is the regulator and the manufacturer agreeing that something has to be fixed, and the fix is free for as long as the car exists.

The campaigns cover power train:automatic transmission, structure:interior panels:center console, seat belts:pretensioner and engine. Whether the work was actually done on the car in front of you is a question only the VIN can answer, and the manufacturer or NHTSA will answer it free.

Recalls also distort complaint counts. Publicity about a campaign reminds owners that complaining is possible, so reports for a recalled component often spike after the recall rather than before it.

How 2020 compares with the other years

Severe risk for a 2020 — 100th riskiest of the 235 2020 vehicles we can rate. The comparison is always within the same model year, so an older car is never penalised for having had longer to break.

Across the 30 model years of this car that carry enough reports to score, 2026 comes out best at 58 and 2003 worst at 78, with 2020 itself at 77.

If the model year is negotiable, 2026, 2014, 2013, 2000, 2002, 2001, 1999, 2010, 2025, 2011, 1998, 1997, 2007, 2008, 2015, 2016, 2022, 2023, 2017, 2009, 2012, 2024 and 2021 score lower than 2020 by a margin worth acting on. Same body, same engines, different luck — usually a supplier change or a mid-cycle fix, which the complaint data can show but never explain.

Within the 2018–2021 generation specifically, 2021 is the strongest year at 74 and 2018 the weakest at 78.

What the numbers say to check

The mileages below are where the first quarter of reports for each mode had already been filed, which makes them the point at which a fault is worth looking for rather than the point at which it happens: other engine problem from about 28k and other powertrain problem from about 40k.

On a 2020 Ford Expedition with more miles than that on it, the useful question to put to a seller or a mechanic is whether other engine problem has been dealt with, and if so with what parts and at whose expense. A car that has already had the repair is in a different position from one that has not.

None of this is a diagnosis. It is a list of what other owners of the same model year reported, ordered by when they reported it, which is a good place to point an inspection and a poor place to stop.

What this page cannot tell you

525 owner reports; fleet size estimated from this year's own recall paperwork. Every count on this page is therefore a floor: it is the number of owners who went to the trouble of filing with a federal agency, which is a small and self-selected fraction of the owners who had the fault.

Of those 525 reports, 118 carried an odometer reading, so the mileages here describe 22% of the sample rather than all of it. Owners also round: readings pile up on multiples of ten thousand, which is why this site publishes "about 90,000 miles" and not "91,438".

Named failure modes come from matching phrases in the complaint text, so a badly worded complaint can land in the wrong bucket. The effect washes out across hundreds of reports and does not wash out across five.

And nothing here predicts what one car will do. These are other people's complaints, filed years apart, on cars maintained by strangers. Read the page as a map of where this model year has previously gone wrong, then have the specific car in front of you inspected.