2002 Dodge Intrepid: what breaks, and at what mileage

The failures owners actually file about

Owners have reported 52 named failure modes on the 2002 Dodge Intrepid, and the three most-reported carry 42% of everything filed.

Other engine problem leads with 118 reports, about 2.1 per 1,000 vehicles and with the middle half of reports between 59k to 106,000 miles.

Other powertrain problem follows with 29 reports, usually reported between 50k to 80,000 miles. 1 of those report mention a fire.

Timing chain, belt or tensioner failure follows with 27 reports, usually reported between 54k to 100,000 miles.

By system, the reports fall mostly into engine (192), transmission (53) and cooling (49).

How bad it is when it goes

Across the named modes, 8 mention a crash, 12 a fire and 5 an injury. Those are the words owners used in their own complaints, and NHTSA does not verify them, but they are the closest thing in this data to a measure of what a failure actually did.

The average severity weight across every report on this year is 4.73, where a stalled engine or a failed airbag weighs many times more than a rattling trim panel, and a figure this high means the reports are dominated by failures with safety consequences rather than annoyances. The weighting is set out in full on the methodology page.

What the top failures cost to put right, as editorial estimates for an independent US shop rather than figures from NHTSA: other engine problem at $300–$4,000, other powertrain problem at $400–$4,500, timing chain, belt or tensioner failure at $1,200–$4,500 and complete transmission failure at $2,800–$8,000. Dealer labour, a seized bolt or a part that is no longer made can push any of these past the top of its range.

71% of the reports on this year sit in the engine, transmission, drivetrain or cooling systems — the four where a repair bill is usually four figures, so more than half of what owners complained about here is expensive.

How often, against how many were built

Scaled by an estimate of how many of these cars exist, the 2002 Dodge Intrepid draws about 7.4 per 1,000 vehicles, which puts it in the 84th percentile of complaint rates among 2002 vehicles we can rate.

That denominator is the weakest number on the page and it is fair to say so plainly. Rate per 1,000 uses a fleet-size estimate derived from recall paperwork for this exact model year. It is a lower bound.

The working figure is 56,105 vehicles. If the true number is twice that, every rate on this page is half what it says; the ranking against other 2002 vehicles, which is what the risk score uses, is far more robust than the rate itself.

Recalls on the 2002 model year

NHTSA has issued 3 recall campaigns covering the 2002 Dodge Intrepid, affecting an estimated 56,232 vehicles. A recall is a different kind of evidence from a complaint: it is the regulator and the manufacturer agreeing that something has to be fixed, and the fix is free for as long as the car exists.

The campaigns cover exterior lighting:headlights, exterior lighting and seats:front assembly:recliner. Whether the work was actually done on the car in front of you is a question only the VIN can answer, and the manufacturer or NHTSA will answer it free.

One caution about reading these together: a recall usually raises the complaint count for the same part, because owners who read about it go and file. The mileages stay informative; the counts get noisy.

Better and worse years of the same car

High risk for a 2002 — 120th riskiest of the 329 2002 vehicles we can rate. Because the ranking is against the same model year only, age cancels out of it.

Across the 9 model years of this car that carry enough reports to score, 1996 comes out best at 64 and 2003 worst at 78, with 2002 itself at 70.

If the model year is negotiable, 1996 and 1997 score lower than 2002 by a margin worth acting on. Same body, same engines, different luck — usually a supplier change or a mid-cycle fix, which the complaint data can show but never explain.

Within the 1999–2004 generation specifically, 2002 is the strongest year at 70 and 2003 the weakest at 78.

Where to spend the inspection money

The mileages below are where the first quarter of reports for each mode had already been filed, which makes them the point at which a fault is worth looking for rather than the point at which it happens: steering rack, gear or tie rod failure from about 37k, other powertrain problem from about 50k, complete transmission failure from about 52k and timing chain, belt or tensioner failure from about 54k.

On a 2002 Dodge Intrepid with more miles than that on it, the useful question to put to a seller or a mechanic is whether steering rack, gear or tie rod failure has been dealt with, and if so with what parts and at whose expense. A car that has already had the repair is in a different position from one that has not.

Treat it as where to point the inspection, not as a prediction. A well-maintained example can sail past every mileage on this page, and a neglected one can fail well before the first of them.

The limits of complaint data

413 owner reports; fleet size estimated from this year's own recall paperwork. Every count on this page is therefore a floor: it is the number of owners who went to the trouble of filing with a federal agency, which is a small and self-selected fraction of the owners who had the fault.

Of those 413 reports, 317 carried an odometer reading, so the mileages here describe 77% of the sample rather than all of it. Owners also round: readings pile up on multiples of ten thousand, which is why this site publishes "about 90,000 miles" and not "91,438".

The failure modes are assigned by software reading the owner's own words, which is accurate in bulk and wrong in individual cases. A mode with a handful of reports may contain a misfiled one.

And nothing here predicts what one car will do. These are other people's complaints, filed years apart, on cars maintained by strangers. Read the page as a map of where this model year has previously gone wrong, then have the specific car in front of you inspected.