1998 Dodge Intrepid: what breaks, and at what mileage

What owners report breaking

Owners have reported 54 named failure modes on the 1998 Dodge Intrepid, and the three most-reported carry 35% of everything filed.

Other engine problem leads with 126 reports, about 1.7 per 1,000 vehicles and with the middle half of reports between 74k to 105,000 miles.

Complete engine failure or seizure follows with 27 reports, usually reported between 71k to 100,000 miles. 1 of those report mention a fire.

Other powertrain problem follows with 22 reports, median 95,000 miles.

By system, the reports fall mostly into engine (197), brakes (45) and electrical (35).

What happens when these parts fail

Across the named modes, 27 mention a crash, 10 a fire, 16 an injury and 3 a fatality. Those are the words owners used in their own complaints, and NHTSA does not verify them, but they are the closest thing in this data to a measure of what a failure actually did.

The average severity weight across every report on this year is 5.08, where a stalled engine or a failed airbag weighs many times more than a rattling trim panel, and a figure this high means the reports are dominated by failures with safety consequences rather than annoyances. The weighting is set out in full on the methodology page.

What the top failures cost to put right, as editorial estimates for an independent US shop rather than figures from NHTSA: other engine problem at $300–$4,000, complete engine failure or seizure at $4,500–$12,000, other powertrain problem at $400–$4,500 and steering rack, gear or tie rod failure at $700–$2,600. Dealer labour, a seized bolt or a part that is no longer made can push any of these past the top of its range.

53% of the reports on this year sit in the engine, transmission, drivetrain or cooling systems — the four where a repair bill is usually four figures, so more than half of what owners complained about here is expensive.

How often, against how many were built

Scaled by an estimate of how many of these cars exist, the 1998 Dodge Intrepid draws about 6.6 per 1,000 vehicles, which puts it in the 85th percentile of complaint rates among 1998 vehicles we can rate.

That denominator is the weakest number on the page and it is fair to say so plainly. Rate per 1,000 uses a fleet-size estimate derived from recall paperwork for this exact model year. It is a lower bound.

The working figure is 74,702 vehicles. If the true number is twice that, every rate on this page is half what it says; the ranking against other 1998 vehicles, which is what the risk score uses, is far more robust than the rate itself.

Recalls on the 1998 model year

NHTSA has issued 5 recall campaigns covering the 1998 Dodge Intrepid, affecting an estimated 130,988 vehicles. A recall is a different kind of evidence from a complaint: it is the regulator and the manufacturer agreeing that something has to be fixed, and the fix is free for as long as the car exists.

The campaigns cover exterior lighting:headlights, exterior lighting, power train:automatic transmission:lever and linkage:floor s and seats:front assembly:recliner. Whether the work was actually done on the car in front of you is a question only the VIN can answer, and the manufacturer or NHTSA will answer it free.

Recalls also distort complaint counts. Publicity about a campaign reminds owners that complaining is possible, so reports for a recalled component often spike after the recall rather than before it.

How 1998 compares with the other years

High risk for a 1998 — 41st riskiest of the 271 1998 vehicles we can rate. The comparison is always within the same model year, so an older car is never penalised for having had longer to break.

Across the 9 model years of this car that carry enough reports to score, 1996 comes out best at 64 and 2003 worst at 78, with 1998 itself at 70.

If the model year is negotiable, 1996 and 1997 score lower than 1998 by a margin worth acting on. Same body, same engines, different luck — usually a supplier change or a mid-cycle fix, which the complaint data can show but never explain.

Within the 1996–1998 generation specifically, 1996 is the strongest year at 64 and 1998 the weakest at 70.

What to look at before buying one

The mileages below are where the first quarter of reports for each mode had already been filed, which makes them the point at which a fault is worth looking for rather than the point at which it happens: steering rack, gear or tie rod failure from about 31k, timing chain, belt or tensioner failure from about 67k, complete engine failure or seizure from about 71k and other engine problem from about 74k.

On a 1998 Dodge Intrepid with more miles than that on it, the useful question to put to a seller or a mechanic is whether steering rack, gear or tie rod failure has been dealt with, and if so with what parts and at whose expense. A car that has already had the repair is in a different position from one that has not.

None of this is a diagnosis. It is a list of what other owners of the same model year reported, ordered by when they reported it, which is a good place to point an inspection and a poor place to stop.

The limits of complaint data

493 owner reports; fleet size estimated from this year's own recall paperwork. Every count on this page is therefore a floor: it is the number of owners who went to the trouble of filing with a federal agency, which is a small and self-selected fraction of the owners who had the fault.

Of those 493 reports, 232 carried an odometer reading, so the mileages here describe 47% of the sample rather than all of it. Owners also round: readings pile up on multiples of ten thousand, which is why this site publishes "about 90,000 miles" and not "91,438".

Named failure modes come from matching phrases in the complaint text, so a badly worded complaint can land in the wrong bucket. The effect washes out across hundreds of reports and does not wash out across five.

And nothing here predicts what one car will do. These are other people's complaints, filed years apart, on cars maintained by strangers. Read the page as a map of where this model year has previously gone wrong, then have the specific car in front of you inspected.