Other steering problem on the 2004 Chevrolet Impala
6 crashes 3 injuries 9 of the 22 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
When other steering problem gets reported
Owners of the 2004 Chevrolet Impala report other steering problem at a median of 80,000 miles. A quarter of the reports come in before 50,000 miles and a quarter after 100,000 miles, from 15 reports that carried an odometer reading.
A part like this is normally expected to survive 95,000 miles. It is the 16th most-reported problem on this model year.
The mileage distribution
The reported range runs from 5,000 miles at the tenth percentile to 105,000 miles at the ninetieth, a spread of 100,269 miles across the middle 80% of reports.
A spread this wide points at use rather than design. Towing, climate, service history and city mileage all move a failure like this, so the median is a weak guide to any individual car.
20% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 5,731 miles | 51,937 miles | 78,000 miles | 98,000 miles | 106,000 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 6 a crash and 3 an injury are mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $350–$2,400 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 20 model years of this car. It shows up earliest on the 2017, at a median of 30,000 miles, and latest on the 2000 at 110,000 miles.
By volume the 2014 carries the most reports, with 90; the 2004 has 22. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
There are no things that lead up to the the steering problem. The problem is with car that has 3018 miles on it I should have no problems. The steering clicks when turned to the left and right. Dealer will get me a rental car if the car warrenty work is more then 2 hours or car needs to be kept overnight. *ak
After purchasing vehicle took it back to have steering checked because it did not feel or sound right when doing a braking and turning steering wheel combination. Mentioned the NHTSA recall of 2004 impala. Was told did not involve ss. On this occasion was unable to stop the vehicle, unable to steer properly, could not control vehicle. It spiraled and hit a bus stop/pole. *tr
The speedometer started getting stuck about six months ago. For about eight months I have noticed that when I turn the steering wheel I hear a noise in the front of the car, like a knock or something. Also within the last couple of months I have also smelled gas when I first start the car , my husband could not see any leakage or anything until last week. It was leaking from the fuel regulator valve. Now the transmission is starting to shift hard sometimes. I haven't had the money to get it all checked out by the manufacturer but I was wondering if there have been any complaints on any of these things. Also I can hear a whistling sound when I press the accelerator. And my husband just informed me that he bought a regulator valve for it and some o rings because something is leaking antifreeze slightly. Can you help please!!!!!!!! *tr
Also reported on the 2004 Chevrolet Impala
Instrument cluster or gauge failure
Other electrical problem
No-start or intermittent start failure
Ignition switch, key fob or immobilizer failure
Other engine problem
Other lighting problem
How far this goes
Complaints are voluntary, so 22 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does other steering problem happen on the 2004 Chevrolet Impala?
Across 15 owner reports that included an odometer reading, half were filed by 80,000 miles. A quarter were filed before 50,000 miles and a quarter after 100,000 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is other steering problem on the 2004 Chevrolet Impala?
22 reports have been filed with NHTSA, about 0.2 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed