Control module (ECM/PCM/BCM) failure on the 2012 Dodge Grand Caravan
Only 4 reports for this mode came with an odometer reading, which is too few for percentiles to mean anything. The page is here because someone linked to it; treat the figures as anecdotes, and see the full report for this year instead.
When control module (ecm/pcm/bcm) failure gets reported
There are 5 reports of control module (ECM/PCM/BCM) failure on the 2012 Dodge Grand Caravan, 4 with a mileage attached. That is too few to place the failure on the odometer with any confidence.
A part like this is normally expected to survive 92,000 miles. It is the 22nd most-reported problem on this model year.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| — | — | 82,500 miles | — | — |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Putting it right typically runs $700–$3,000 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 18 model years of this car. It shows up earliest on the 2003, at a median of 35,000 miles, and latest on the 1996 at 90,000 miles.
By volume the 2005 carries the most reports, with 109; the 2012 has 5. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
Tl* the contact owns a 2012 dodge grand caravan. After the vehicle was started, the air bag warning light illuminated. The vehicle was taken to a dealer where it was diagnosed that the air bag control module needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 51,000. Ma 10/22/2015 *cn
3 instances of engine electrical issues, suspect power control module box. First instance about 2 years ago, pulling into driveway, and headlights and dashboard begin to flicker uncontrollably. I pulled negative battery cable, re-connected after a couple of minutes, and all normality returns. 2nd issue, some year ago or less, car shuts down in middle of highway, luckily, right next to a parking lot and red light. As engine shut down, I suspected this issue once again. I used momentum to turn into parking lot. (just rolled in.) wife asked me what I was doing, didn't explain until I was able to secure into parking lot and stop vehicle. Once again, pulled off cable on battery, and was able to re-set computer glitch. Third issue event. Was parked in parking lot, couldn't get key control to open door. Used emergency key to open door, once again, pulled off battery cable and re-set computer. There is a problem with this computer without a doubt.
Over the past 5 months, vehicle disengaging from park and into drive is clunky. Recently on a highway (vehicle in motion with children in the car), transmission would not shift out of 2nd/3rd. Vehicle was parked the rest of the day. Next morning it seemed to drive fine. Later same day shifting issue returned. Took it to a transmission specialist for diagnostic. Took it to the dealer. Vehicle is just over 100k miles (no longer under warranty). The solenoid pack was replaced. Vehicle was purchased new with 14 miles. Pcm was recalled at 24k. Left side cylinder head replaced at 33k.
Also reported on the 2012 Dodge Grand Caravan
Other electrical problem
Other engine problem
Fuel pump failure
No-start or intermittent start failure
Stalling while driving
Other powertrain problem
How far this goes
This page is kept out of search results because 5 reports is not enough to publish percentiles from. It stays reachable because somebody looking at this exact car would rather see the reports than be told there are none.
Complaints are voluntary, so 5 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does control module (ecm/pcm/bcm) failure happen on the 2012 Dodge Grand Caravan?
Across 4 owner reports that included an odometer reading, half were filed by 85,000 miles. A quarter were filed before — and a quarter after —. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is control module (ecm/pcm/bcm) failure on the 2012 Dodge Grand Caravan?
5 reports have been filed with NHTSA, about 0.0 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed