Control module (ECM/PCM/BCM) failure on the 2001 Dodge Grand Caravan
When control module (ecm/pcm/bcm) failure gets reported
Owners of the 2001 Dodge Grand Caravan report control module (ECM/PCM/BCM) failure at a median of 45,000 miles. A quarter of the reports come in before 35,000 miles and a quarter after 75,000 miles, from 18 reports that carried an odometer reading.
A part like this is normally expected to survive 92,000 miles. It is the 3rd most-reported problem on this model year.
The mileage distribution
The reported range runs from 5,000 miles at the tenth percentile to 100,000 miles at the ninetieth, a spread of 91,832 miles across the middle 80% of reports.
A spread this wide points at use rather than design. Towing, climate, service history and city mileage all move a failure like this, so the median is a weak guide to any individual car.
39% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 7,253 miles | 34,250 miles | 43,000 miles | 74,000 miles | 99,085 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Putting it right typically runs $700–$3,000 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 18 model years of this car. It shows up earliest on the 2003, at a median of 35,000 miles, and latest on the 1996 at 90,000 miles.
By volume the 2005 carries the most reports, with 109; the 2001 has 23. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
Dodge gc 2001 stalled while in motion with no warning during a very heavily traveled area in a school zone with many potential hazards. Luckily I was only going about 10 mphs and coming to a stop. I interrupted flow of traffic at time of failure and when the tow truck came. A police officer helped direct traffic. Mechanic said leak detection pump went out which caused the PCM (power train control module) to short out. This PCM controls many electrical elements. The engine light is on, the speedometer and passenger window doesnt work and I am told that several systems could fail but it is driveable. I have searched many dealerships in many states with all the same answer. The part I need, the PCM, is on national back order. There are none available in the us. This is the only vehicle I have to transport my children. I contacted dc corp and they will not tell me if it is safe to drive w/ a faulty PCM. It has been 3 weeks and my van is not fixed. I am at their mercy and they have denied responsibility as well as a rental request until my van can be fixed properly. "unfortunately, your request for a rental vehicle has been declined."…
Dodge gc 2001 stalled while in motion with no warning during a very heavily traveled area in a school zone with many potential hazards. Luckily I was only going about 10 mphs and coming to a stop. I interrupted flow of traffic at time of failure and when the tow truck came. A police officer helped direct traffic. Mechanic said leak detection pump went out which caused the PCM (power train control module) to short out. This PCM controls many electrical elements. The engine light is on, the speedometer and passenger window doesnt work and I am told that several systems could fail but it is driveable. I have searched many dealerships in many states with all the same answer. The part I need, the PCM, is on national back order. There are none available in the us. This is the only vehicle I have to transport my children. I contacted dc corp and they will not tell me if it is safe to drive w/ a faulty PCM. It has been 3 weeks and my van is not fixed. I am at their mercy and they have denied responsibility as well as a rental request until my van can be fixed properly. "unfortunately, your request for a rental vehicle has been declined."…
I own a 2001 grand caravan sport. At 35,000 miles I brought it to a dealer for the 30,000 mile check and to service a grinding noise in the AC unit and a shudder when turning at slow speeds. They fixed the AC and shudder by truing the rotors and new pads, however they also said there was a bulletin out on the steering pump and the unit was on back order...would call when it came in...yeah right. After an attempt on my part 3 months later to locate this pump, I gave up trying and continued driving. At 54,000 miles, I againg brought in my car because the AC compressor failed due to another bulletin on the PCM unit. I inquired about fixing the old problem with the pump and they admitted they made a mistake by not ordering the pump or contacting me but they would not honor the repair becaues it was now out of warranty and they would have to pay for it...even though it was under warranty when I brought it in and they admit to their mistake!!! Never again for dodge...in fact, we are selling it to buy a honda.*ak
Also reported on the 2001 Dodge Grand Caravan
Headlight failure or clouding
Airbag warning light or occupant sensor fault
Other lighting problem
Other visibility problem
Other electrical problem
Other body or interior problem
How far this goes
Complaints are voluntary, so 23 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does control module (ecm/pcm/bcm) failure happen on the 2001 Dodge Grand Caravan?
Across 18 owner reports that included an odometer reading, half were filed by 45,000 miles. A quarter were filed before 35,000 miles and a quarter after 75,000 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is control module (ecm/pcm/bcm) failure on the 2001 Dodge Grand Caravan?
23 reports have been filed with NHTSA, about 0.8 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed