2020 Chevrolet Traverse: what breaks, and at what mileage

What owners report breaking

Owners have reported 53 named failure modes on the 2020 Chevrolet Traverse, and the three most-reported carry 27% of everything filed, which is an unusually even spread for one model year.

Other engine problem leads with 40 reports, about 7.4 per 1,000 vehicles and with the middle half of reports between 50k to 80,000 miles.

Other powertrain problem follows with 23 reports, median 65,000 miles.

Other electrical problem follows with 18 reports, median 105,000 miles.

By system, the reports fall mostly into engine (63), transmission (31) and emissions (31).

How bad it is when it goes

Across the named modes, 17 mention a crash, 2 a fire and 7 an injury. Those are the words owners used in their own complaints, and NHTSA does not verify them, but they are the closest thing in this data to a measure of what a failure actually did.

The average severity weight across every report on this year is 4.04, where a stalled engine or a failed airbag weighs many times more than a rattling trim panel, and a figure this high means the reports are dominated by failures with safety consequences rather than annoyances. The weighting is set out in full on the methodology page.

What the top failures cost to put right, as editorial estimates for an independent US shop rather than figures from NHTSA: other engine problem at $300–$4,000, other powertrain problem at $400–$4,500, other electrical problem at $250–$2,000 and exhaust leak or fumes in the cabin at $250–$2,000. Dealer labour, a seized bolt or a part that is no longer made can push any of these past the top of its range.

33% of the reports on this year sit in the engine, transmission, drivetrain or cooling systems — the four where a repair bill is usually four figures.

How often, against how many were built

Scaled by an estimate of how many of these cars exist, the 2020 Chevrolet Traverse draws about 55 per 1,000 vehicles, which puts it in the 98th percentile of complaint rates among 2020 vehicles we can rate.

That denominator is the weakest number on the page and it is fair to say so plainly. Rate per 1,000 uses a fleet-size estimate derived from recall paperwork for this exact model year. It is a lower bound.

The working figure is 5,391 vehicles. If the true number is twice that, every rate on this page is half what it says; the ranking against other 2020 vehicles, which is what the risk score uses, is far more robust than the rate itself.

Recalls on the 2020 model year

NHTSA has issued 8 recall campaigns covering the 2020 Chevrolet Traverse, affecting an estimated 8,806 vehicles. A recall is a different kind of evidence from a complaint: it is the regulator and the manufacturer agreeing that something has to be fixed, and the fix is free for as long as the car exists.

The campaigns cover air bags:side/window:curtain, power train:automatic transmission and tires. Whether the work was actually done on the car in front of you is a question only the VIN can answer, and the manufacturer or NHTSA will answer it free.

One caution about reading these together: a recall usually raises the complaint count for the same part, because owners who read about it go and file. The mileages stay informative; the counts get noisy.

Better and worse years of the same car

Severe risk for a 2020 — 33rd riskiest of the 235 2020 vehicles we can rate. The comparison is always within the same model year, so an older car is never penalised for having had longer to break.

Across the 18 model years of this car that carry enough reports to score, 2017 comes out best at 68 and 2020 worst at 81, with 2020 itself at 81.

If the model year is negotiable, 2017, 2015, 2016, 2013, 2014, 2012, 2025, 2024, 2010, 2009, 2011, 2026, 2021, 2022 and 2023 score lower than 2020 by a margin worth acting on. Same body, same engines, different luck — usually a supplier change or a mid-cycle fix, which the complaint data can show but never explain.

Within the 2018–2021 generation specifically, 2021 is the strongest year at 75 and 2020 the weakest at 81.

What the numbers say to check

The mileages below are where the first quarter of reports for each mode had already been filed, which makes them the point at which a fault is worth looking for rather than the point at which it happens: other engine problem from about 50k.

On a 2020 Chevrolet Traverse with more miles than that on it, the useful question to put to a seller or a mechanic is whether other engine problem has been dealt with, and if so with what parts and at whose expense. A car that has already had the repair is in a different position from one that has not.

Treat it as where to point the inspection, not as a prediction. A well-maintained example can sail past every mileage on this page, and a neglected one can fail well before the first of them.

The limits of complaint data

296 owner reports; fleet size estimated from this year's own recall paperwork. Every count on this page is therefore a floor: it is the number of owners who went to the trouble of filing with a federal agency, which is a small and self-selected fraction of the owners who had the fault.

Of those 296 reports, 72 carried an odometer reading, so the mileages here describe 24% of the sample rather than all of it. Owners also round: readings pile up on multiples of ten thousand, which is why this site publishes "about 90,000 miles" and not "91,438".

The failure modes are assigned by software reading the owner's own words, which is accurate in bulk and wrong in individual cases. A mode with a handful of reports may contain a misfiled one.

And nothing here predicts what one car will do. These are other people's complaints, filed years apart, on cars maintained by strangers. Read the page as a map of where this model year has previously gone wrong, then have the specific car in front of you inspected.