Wiring harness or short circuit on the 2005 Chevrolet Silverado 2500
4 fires 2 injuries 6 of the 8 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
Only 6 reports for this mode came with an odometer reading, which is too few for percentiles to mean anything. The page is here because someone linked to it; treat the figures as anecdotes, and see the full report for this year instead.
When wiring harness or short circuit gets reported
There are 8 reports of wiring harness or short circuit on the 2005 Chevrolet Silverado 2500, 6 with a mileage attached. That is too few to place the failure on the odometer with any confidence.
A part like this is normally expected to survive 88,000 miles. It is the 11th most-reported problem on this model year.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| — | — | 57,000 miles | — | — |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 4 a fire and 2 an injury are mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $400–$3,500 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 8 model years of this car. It shows up earliest on the 2020, at a median of 20,000 miles, and latest on the 2013 at 170,000 miles.
By volume the 2020 carries the most reports, with 12; the 2005 has 8. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
Tl*the contact owns a 2005 chevrolet silverado 2500. The contact used the lighter installed in the vehicle to light a cigarette. Minutes later, he noticed blue smoke emanating from the instrument control cluster. Upon further inspection, he noticed that the wiring in the fuse box melted. The contact took the vehicle to the dealer and they stated that the wiring harness and fuse box needed to be replaced at the cost of over $2,500. The vehicle has not been repaired. He is in the process of notifying the manufacturer. The failure and current mileages were 64,000.
I was pulling out of a side street on to a busy highway had to merge quickly the truck would not accelerate engine was skipping check engine light comes on had to pull over all most got hit by traffic due to the lack of power and not able accelerate I take the truck to dealer they have it 3 days working on wiring harness shorts to injector 6 caused by improper wiring harness routing I had to inform them of gm tsb on this they fix it and said not covered under engine warranty costs $370 this truck was in may 09 for skip and p1238 open circuit injector 6 and problem was not found cost $100 the tsb had been out since 07 this is very dangerous when crossing busy highways and loss of power occurs. *tr
I was pulling out of a side street on to a busy highway had to merge quickly the truck would not accelerate engine was skipping check engine light comes on had to pull over all most got hit by traffic due to the lack of power and not able accelerate I take the truck to dealer they have it 3 days working on wiring harness shorts to injector 6 caused by improper wiring harness routing I had to inform them of gm tsb on this they fix it and said not covered under engine warranty costs $370 this truck was in may 09 for skip and p1238 open circuit injector 6 and problem was not found cost $100 the tsb had been out since 07 this is very dangerous when crossing busy highways and loss of power occurs. *tr
Also reported on the 2005 Chevrolet Silverado 2500
Instrument cluster or gauge failure
Other electrical problem
Loss of braking
Other brake problem
Other steering problem
Brake line, hose or caliper failure
How far this goes
This page is kept out of search results because 8 reports is not enough to publish percentiles from. It stays reachable because somebody looking at this exact car would rather see the reports than be told there are none.
Complaints are voluntary, so 8 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does wiring harness or short circuit happen on the 2005 Chevrolet Silverado 2500?
Across 6 owner reports that included an odometer reading, half were filed by 55,000 miles. A quarter were filed before — and a quarter after —. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is wiring harness or short circuit on the 2005 Chevrolet Silverado 2500?
8 reports have been filed with NHTSA, about 131 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed