Cruise control failure on the 2005 Ford Explorer
1 fire 1 of the 20 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
When cruise control failure gets reported
Owners of the 2005 Ford Explorer report cruise control failure at a median of 65,000 miles. A quarter of the reports come in before 25,000 miles and a quarter after 85,000 miles, from 15 reports that carried an odometer reading.
A part like this is normally expected to survive 72,000 miles. It is the 10th most-reported problem on this model year.
The mileage distribution
The reported range runs from 5,000 miles at the tenth percentile to 130,000 miles at the ninetieth, a spread of 124,210 miles across the middle 80% of reports.
When the reports scatter this far, the mileage is telling you about how these cars were driven more than about the part itself.
47% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 5,890 miles | 25,250 miles | 65,000 miles | 82,500 miles | 130,100 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 1 a fire is mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $200–$1,400 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 22 model years of this car. It shows up earliest on the 2023, at a median of 5,000 miles, and latest on the 2014 at 145,000 miles.
By volume the 1998 carries the most reports, with 67; the 2005 has 20. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
Dt: the contact owns a 2005 ford explorer. When stepping on the accelerator there is a delayed throttle response of 3-5 seconds before one feels any acceleration. The contact noticed this after he bought the car in 8-05. He took it to the dealer, and they agreed with him. They test drove another 2005 ford explorer and it did the same thing. The dealer called ford, and ford said they knew about this, and they allowed the transmission to shift before it accelerated. They will not allow the dealership to change this. It happened whether the cruise control was on or off. It happens at any speed.*ak *nm
Dt*: the contact stated when activating the cruise control and the speed set at 70 MPH, the cruise control deactivates itself with no interaction from the contact. The vehicle was taken to the dealer for inspection; however the problem could not be duplicated. Vehicle speed control deactivated 3 times while in use. In february 2006, after speed control deactivated it took 3 to 5 minutes to turn it back on. Dealer found no problem. In march 2006, it deactivated once. *ak
Our vehicle is a 2005 ford explorer. With the cruise control set and coasting with the coast button down to 30 MPH the car shuts off. We just had the car checked at courtesy ford in portland oregon and were told that everything checks out and there is nothing wrong with the car. Service was able to reproduce our car shutting off with the cruise control on when coasting to 30 MPH. I filed a complaint with ford customer care and was also told that all systems checked out and there is nothing wrong with our car. Courtesy ford was not able to reproduce this problem in 3 other newer model explorers, but today were able to reproduce this problem in 2 other 2005 explorers.
Also reported on the 2005 Ford Explorer
Other body or interior problem
Other powertrain problem
Liftgate, tailgate or trunk failure
Other engine problem
Other fuel system problem
Other electrical problem
How far this goes
Complaints are voluntary, so 20 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does cruise control failure happen on the 2005 Ford Explorer?
Across 15 owner reports that included an odometer reading, half were filed by 65,000 miles. A quarter were filed before 25,000 miles and a quarter after 85,000 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is cruise control failure on the 2005 Ford Explorer?
20 reports have been filed with NHTSA, about 116 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed