Other fuel system problem on the 1996 Dodge Grand Caravan
10 fires 10 of the 55 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
Only 7 reports for this mode came with an odometer reading, which is too few for percentiles to mean anything. The page is here because someone linked to it; treat the figures as anecdotes, and see the full report for this year instead.
When other fuel system problem gets reported
There are 55 reports of other fuel system problem on the 1996 Dodge Grand Caravan, 7 with a mileage attached. That is too few to place the failure on the odometer with any confidence.
A part like this is normally expected to survive 90,000 miles. It is the 10th most-reported problem on this model year.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| — | — | 130,000 miles | — | — |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 10 a fire is mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $300–$2,200 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 21 model years of this car. It shows up earliest on the 2019, at a median of 4 miles, and latest on the 1999 at 210,000 miles.
By volume the 1996 is the worst of them, which makes this a problem of this specific year rather than of the model as a whole.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
On december 05/2002 my 1996 dodge grand caravan caught on fire. The car was just warming up prior to being used to take my kids to school. The fire was extinguished by the dekalb county, georgia fire department. I learned after the fire that chrysler had a recall related to a fuel rail/system defect. I have all major mechanic work done at the authorized chrysler dealership and was never told of this recall.
A/c internal fan switch fails in at least two positions and have had smoke enter inside the van while driving, from I think the fan. Once the fan is turned off the smoke goes away.
Tl* - the contact's vehicle was taken to the dealer for recall 00v268000 repairs. The dealer told the contact that the recall repairs had already been made on the vehicle per recall requirements. This repair was done on december 11, 2006. On january 2, 2007 after driving approximate 6 miles the driver smelled gas fumes so he drove the vehicle back home. The contact stated that the gas fumes killed 14 of the birds that were housed in his garage. The contact opened the hood and gas was leaking. The contact stated that he had noticed the vehicle was using more gas than it had previously. The vehicle was still slowly leaking gas 24 hours after he originally noticed the leak. The contact stated that the vehicle was not drivable and he has not yet contacted the dealer. The contact stated the check engine light was on. *ak updated 2/6/2007 - *nm updated 03/21/07
Also reported on the 1996 Dodge Grand Caravan
Airbag warning light or occupant sensor fault
Cruise control failure
Other engine problem
Other powertrain problem
Fuel tank, filler or EVAP failure
Other body or interior problem
How far this goes
This page is kept out of search results because 55 reports is not enough to publish percentiles from. It stays reachable because somebody looking at this exact car would rather see the reports than be told there are none.
Complaints are voluntary, so 55 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does other fuel system problem happen on the 1996 Dodge Grand Caravan?
Across 7 owner reports that included an odometer reading, half were filed by 130,000 miles. A quarter were filed before — and a quarter after —. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is other fuel system problem on the 1996 Dodge Grand Caravan?
55 reports have been filed with NHTSA, about 0.4 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed