Control module (ECM/PCM/BCM) failure on the 2009 Dodge Challenger
Only 6 reports for this mode came with an odometer reading, which is too few for percentiles to mean anything. The page is here because someone linked to it; treat the figures as anecdotes, and see the full report for this year instead.
When control module (ecm/pcm/bcm) failure gets reported
There are 6 reports of control module (ECM/PCM/BCM) failure on the 2009 Dodge Challenger, 6 with a mileage attached. That is too few to place the failure on the odometer with any confidence.
A part like this is normally expected to survive 92,000 miles. It is the 7th most-reported problem on this model year.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| — | — | 15,539 miles | — | — |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Putting it right typically runs $700–$3,000 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 3 model years of this car. It shows up earliest on the 2009, at a median of 15,000 miles, and latest on the 2010 at 50,000 miles.
By volume the 2010 carries the most reports, with 7; the 2009 has 6. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
The dealership flashed the PCM as detailed in service bulletin 18-021-09 rev. A. Immediately after that I noticed an intermittent throttle lag. When pressing the gas pedal, the car will wait 1/2 to 3/4 second, then the engine will respond and the car will go. Merging into highway traffic is now dangerous as the car will not always respond to the pedal input. When it finally does respond the car will surge forward (since I'm pushing down more on the pedal trying to get the car to move). This is dangerous as the rear tires can lose traction on wet roads. The dealership hooked up a portable data logger and road tested the vehicle. They were able to verify the complaint. They sent the results to chrysler's engineers. Those engineers reviewed the data and said, "the vehicle is operating as designed, delay is normal, we see nothing wrong." I had the car for 22 months prior to this update and never had the problem before.
The dealership flashed the PCM as detailed in service bulletin 18-021-09 rev. A. Immediately after that I noticed an intermittent throttle lag. When pressing the gas pedal, the car will wait 1/2 to 3/4 second, then the engine will respond and the car will go. Merging into highway traffic is now dangerous as the car will not always respond to the pedal input. When it finally does respond the car will surge forward (since I'm pushing down more on the pedal trying to get the car to move). This is dangerous as the rear tires can lose traction on wet roads. The dealership hooked up a portable data logger and road tested the vehicle. They were able to verify the complaint. They sent the results to chrysler's engineers. Those engineers reviewed the data and said, "the vehicle is operating as designed, delay is normal, we see nothing wrong." I had the car for 22 months prior to this update and never had the problem before.
Took my car into dealership for warranty work on trim and window switch. Car was fine. Had owned it for 2.5 years. Dealer performed flash on PCM per chrylsers information. When I left the dealer, I noteced a 1.5 second delay when gas pedel is depressed. Found out when trying to pass slower traffic. Human nature causes you to press if more. Then all of the sudden, the power comes on hard. Took it back, and had chryler tech test drive with service mgr. They saw the problem with the scan tool hooked up. Was told that there was a 1.4 second delay. Tech said he made changes in program and took it to .7 seconds. I do not see a differance in performance. Called contact at chrysler. And was told that it falls within factory standards. There is no way this is right. Car was fine untill they flashed it. I am unable to get any paperwork from chrysler stating the problem is normal. This is very dangerous. At 55 or 70mph 1.4 seconds can be a lifetime. If a time delay is normal for the fly by wire systems, then I am glad I am not a pilot of a fighter aircraft or new comercal air liner. *tt
Also reported on the 2009 Dodge Challenger
Other engine problem
Other powertrain problem
Airbag inflator rupture
Other electrical problem
Other speed control problem
Timing chain, belt or tensioner failure
How far this goes
This page is kept out of search results because 6 reports is not enough to publish percentiles from. It stays reachable because somebody looking at this exact car would rather see the reports than be told there are none.
Complaints are voluntary, so 6 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does control module (ecm/pcm/bcm) failure happen on the 2009 Dodge Challenger?
Across 6 owner reports that included an odometer reading, half were filed by 15,000 miles. A quarter were filed before — and a quarter after —. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is control module (ecm/pcm/bcm) failure on the 2009 Dodge Challenger?
6 reports have been filed with NHTSA, about 0.1 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed