2001 Chrysler Voyager: what breaks, and at what mileage

What owners report breaking

Owners have reported 31 named failure modes on the 2001 Chrysler Voyager, and the three most-reported carry 33% of everything filed, which is an unusually even spread for one model year.

Airbag warning light or occupant sensor fault leads with 16 reports, about 0.5 per 1,000 vehicles and with the middle half of reports between 45k to 105,000 miles.

Complete transmission failure follows with 8 reports, median 30,000 miles.

Control module (ECM/PCM/BCM) failure follows with 7 reports, median 45,000 miles.

By system, the reports fall mostly into airbag (18), electrical (13) and transmission (12).

Severity, and what it costs

Across the named modes, 1 mentions a crash and 1 an injury. Those are the words owners used in their own complaints, and NHTSA does not verify them, but they are the closest thing in this data to a measure of what a failure actually did.

The average severity weight across every report on this year is 3.61, where a stalled engine or a failed airbag weighs many times more than a rattling trim panel, and a figure this high means the reports are dominated by failures with safety consequences rather than annoyances. The weighting is set out in full on the methodology page.

What the top failures cost to put right, as editorial estimates for an independent US shop rather than figures from NHTSA: airbag warning light or occupant sensor fault at $300–$1,600, complete transmission failure at $2,800–$8,000, control module (ECM/PCM/BCM) failure at $700–$3,000 and other electrical problem at $250–$2,000. Dealer labour, a seized bolt or a part that is no longer made can push any of these past the top of its range.

20% of the reports on this year sit in the engine, transmission, drivetrain or cooling systems — the four where a repair bill is usually four figures.

How often, against how many were built

Scaled by an estimate of how many of these cars exist, the 2001 Chrysler Voyager draws about 3.1 per 1,000 vehicles, which puts it in the 78th percentile of complaint rates among 2001 vehicles we can rate.

That denominator is the weakest number on the page and it is fair to say so plainly. Rate per 1,000 uses a fleet-size estimate derived from recall paperwork for this exact model year. It is a lower bound.

The working figure is 29,750 vehicles. If the true number is twice that, every rate on this page is half what it says; the ranking against other 2001 vehicles, which is what the risk score uses, is far more robust than the rate itself.

Recalls on the 2001 model year

NHTSA has issued 7 recall campaigns covering the 2001 Chrysler Voyager, affecting an estimated 70,787 vehicles. A recall is a different kind of evidence from a complaint: it is the regulator and the manufacturer agreeing that something has to be fixed, and the fix is free for as long as the car exists.

The campaigns cover equipment, service brakes, hydraulic, equipment:electrical:radio/tape deck/cd etc. and fuel system, gasoline. Whether the work was actually done on the car in front of you is a question only the VIN can answer, and the manufacturer or NHTSA will answer it free.

Recalls also distort complaint counts. Publicity about a campaign reminds owners that complaining is possible, so reports for a recalled component often spike after the recall rather than before it.

Better and worse years of the same car

High risk for a 2001 — 254th riskiest of the 320 2001 vehicles we can rate. The comparison is always within the same model year, so an older car is never penalised for having had longer to break.

Across the 5 model years of this car that carry enough reports to score, 2003 comes out best at 61 and 2020 worst at 86, with 2001 itself at 63.

No other year of this model scores meaningfully better than 2001, so if this generation is what you want, the year is not the lever.

Within the 2000–2002 generation specifically, 2001 is the strongest year at 63 and 2002 the weakest at 67.

What to look at before buying one

The mileages below are where the first quarter of reports for each mode had already been filed, which makes them the point at which a fault is worth looking for rather than the point at which it happens: airbag warning light or occupant sensor fault from about 45k.

On a 2001 Chrysler Voyager with more miles than that on it, the useful question to put to a seller or a mechanic is whether airbag warning light or occupant sensor fault has been dealt with, and if so with what parts and at whose expense. A car that has already had the repair is in a different position from one that has not.

None of this is a diagnosis. It is a list of what other owners of the same model year reported, ordered by when they reported it, which is a good place to point an inspection and a poor place to stop.

What this page cannot tell you

93 owner reports; fleet size estimated from this year's own recall paperwork. Every count on this page is therefore a floor: it is the number of owners who went to the trouble of filing with a federal agency, which is a small and self-selected fraction of the owners who had the fault.

Of those 93 reports, 50 carried an odometer reading, so the mileages here describe 54% of the sample rather than all of it. Owners also round: readings pile up on multiples of ten thousand, which is why this site publishes "about 90,000 miles" and not "91,438".

Named failure modes come from matching phrases in the complaint text, so a badly worded complaint can land in the wrong bucket. The effect washes out across hundreds of reports and does not wash out across five.

And nothing here predicts what one car will do. These are other people's complaints, filed years apart, on cars maintained by strangers. Read the page as a map of where this model year has previously gone wrong, then have the specific car in front of you inspected.