Brake line, hose or caliper failure on the 2000 Chevrolet Silverado
4 crashes 4 of the 39 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
When brake line, hose or caliper failure gets reported
Owners of the 2000 Chevrolet Silverado report brake line, hose or caliper failure at a median of 120,000 miles. A quarter of the reports come in before 70,000 miles and a quarter after 137,500 miles, from 29 reports that carried an odometer reading.
A part like this is normally expected to survive 115,000 miles. It is the 14th most-reported problem on this model year.
The mileage distribution
The reported range runs from 52,500 miles at the tenth percentile to 170,000 miles at the ninetieth, a spread of 116,400 miles across the middle 80% of reports.
A spread this wide points at use rather than design. Towing, climate, service history and city mileage all move a failure like this, so the median is a weak guide to any individual car.
3% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 53,200 miles | 70,000 miles | 118,800 miles | 138,000 miles | 169,600 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 4 a crash is mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $250–$1,600 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
This mode is classified as critical, which means a failure can leave the car unable to stop, steer, or stay out of the way of traffic. It is weighted accordingly in the risk score.
The same failure on other years
The same failure is reported on 8 model years of this car. It shows up earliest on the 2006, at a median of 60,000 miles, and latest on the 2001 at 125,000 miles.
By volume the 2003 carries the most reports, with 48; the 2000 has 39. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
The brake line located on the outside of the frame rusted. The line was covered with a thin spring ,and any time it rained or the vehicle went through water, the spring held water right next to the line, causing the line to rust. The dealer replaced the brake line at the expense of the consumer.*ak *ph
Consumer received recall 00 x 001 000 concerning brake hose failure. Consumer was concerned that the brake hose erupted while driving and rust build up on both front rotors.*ak vehicle was hard to stop when coming off a small incline. All four brake pads and rotors needed to be replaced due to rust. *ts
While driving the quarter panel collapsed damaging the brake line, and the emergency brake line. Consumer had an air bag installed on the suspension. However that was damaged also. The tires delaminated. The tread separated from the sidewall of the tires. Firestone steeltex radio, r4f, lt245/75r16, 00-80-11 120/116r m/s, DOT vn11-b1c. *ak
Also reported on the 2000 Chevrolet Silverado
ABS module or sensor failure
Loss of braking
Other brake problem
Other wheel or tire problem
Liftgate, tailgate or trunk failure
Other speed control problem
How far this goes
Complaints are voluntary, so 39 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does brake line, hose or caliper failure happen on the 2000 Chevrolet Silverado?
Across 29 owner reports that included an odometer reading, half were filed by 120,000 miles. A quarter were filed before 70,000 miles and a quarter after 137,500 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is brake line, hose or caliper failure on the 2000 Chevrolet Silverado?
39 reports have been filed with NHTSA, about 0.3 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed