Overheating on the 2003 Chevrolet Silverado 2500
Only 1 report for this mode came with an odometer reading, which is too few for percentiles to mean anything. The page is here because someone linked to it; treat the figures as anecdotes, and see the full report for this year instead.
When overheating gets reported
There are 1 report of overheating on the 2003 Chevrolet Silverado 2500, 1 with a mileage attached. That is too few to place the failure on the odometer with any confidence.
A part like this is normally expected to survive 102,000 miles. It is the 48th most-reported problem on this model year.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| — | — | 58,500 miles | — | — |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Putting it right typically runs $400–$3,500 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 5 model years of this car. It shows up earliest on the 2005, at a median of 35,000 miles, and latest on the 2002 at 245,000 miles.
By volume the 2005 carries the most reports, with 8; the 2003 has 0. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
I filed the formal request below to chevrolet / gm regarding a defective speedometer in my 2003 chevrolet silverado. This is a well known and a well documented problem, and I believe it to be a severe nationwide safety issue which needs to be addressed to avoid possible injury or death. General motors will not repair the problem. Some information is removed to meet the word limit of this complaint form. Gm service request: 71-482347989 silverado safety hazard - a problem I am experiencing with my wife's 2003 silverado 2500 hd is extensive and dangerous. The speedometer is often stuck at random speeds when at rest, and when in motion is unreliable. Information that I have reviewed on several sites indicates that there is a known problem with the stepper motors in the instrument cluster that handle all gauges on this vehicle, and that there are several tsbs that are related to this problem in several gm vehicles. Nhtsa also has several dozen, if not hundreds of reports of this problem. There are also several petitions in progress to demand recalls and / or media investigations. Although my vehicle is out of warranty, this appears to…
Also reported on the 2003 Chevrolet Silverado 2500
Loss of braking
Other brake problem
Brake line, hose or caliper failure
Instrument cluster or gauge failure
Other electrical problem
Differential or transfer case failure
How far this goes
This page is kept out of search results because 1 report is not enough to publish percentiles from. It stays reachable because somebody looking at this exact car would rather see the reports than be told there are none.
Complaints are voluntary, so 1 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does overheating happen on the 2003 Chevrolet Silverado 2500?
Across 1 owner reports that included an odometer reading, half were filed by 60,000 miles. A quarter were filed before — and a quarter after —. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is overheating on the 2003 Chevrolet Silverado 2500?
1 reports have been filed with NHTSA, about 3.4 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed