Tire blowout or tread separation on the 2004 Toyota Camry
1 crash 1 of the 5 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
Only 4 reports for this mode came with an odometer reading, which is too few for percentiles to mean anything. The page is here because someone linked to it; treat the figures as anecdotes, and see the full report for this year instead.
When tire blowout or tread separation gets reported
There are 5 reports of tire blowout or tread separation on the 2004 Toyota Camry, 4 with a mileage attached. That is too few to place the failure on the odometer with any confidence.
A part like this is normally expected to survive 38,000 miles. It is the 27th most-reported problem on this model year.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| — | — | 13,835 miles | — | — |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 1 a crash is mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $200–$1,500 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
This mode is classified as critical, which means a failure can leave the car unable to stop, steer, or stay out of the way of traffic. It is weighted accordingly in the risk score.
The same failure on other years
The same failure is reported on 17 model years of this car. It shows up earliest on the 2020, at a median of 2,100 miles, and latest on the 1999 at 160,000 miles.
By volume the 2002 carries the most reports, with 10; the 2004 has 5. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
Defective bridgestone/firestone tires, request a defect invest.,for tread separation. *bf while driving the vehicle's driver's side rear tire blewout without warning. The tire was original equipment and the vehicle had 7000 miles on the odometer. Neither the dealer nor the tire manufacturer wanted to take responsibility for the tire. *nm
Dt: the consumers vehicle had two blowouts. The first one was on the right rear, and the second one was on the left front. The sidewall of the tires blew out while driving. The speed was 55 MPH. The consumer had been in contact with the manufacturer of the tires. The consumer was in contact with the vehicle manufacturer and they referred him back to the tire manufacturer. The consumer had pieces of the tires available. These were the original tires that had come on his vehicle. *ak (12/08/05) the consumer followed up with the tire manufacturer and they agreed to replace 2 ties at no charge. The tire failures had occurred during the day time on clear days while traveling on the expressway. The vehicle was regularly maintained. *sc
Sudden acceleration caused car loose control and crashed into guardrail. Happened in 3 lane road. Car is total loss . Tire seen blew out thinking happened due to the impact of the hit. *tr
Also reported on the 2004 Toyota Camry
Other speed control problem
Other brake problem
Other steering problem
Other powertrain problem
Other engine problem
Other electrical problem
How far this goes
This page is kept out of search results because 5 reports is not enough to publish percentiles from. It stays reachable because somebody looking at this exact car would rather see the reports than be told there are none.
Complaints are voluntary, so 5 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does tire blowout or tread separation happen on the 2004 Toyota Camry?
Across 4 owner reports that included an odometer reading, half were filed by 15,000 miles. A quarter were filed before — and a quarter after —. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is tire blowout or tread separation on the 2004 Toyota Camry?
5 reports have been filed with NHTSA, about 0.1 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed