Air suspension failure on the 2018 RAM 1500
When air suspension failure gets reported
Owners of the 2018 RAM 1500 report air suspension failure at a median of 10,000 miles. A quarter of the reports come in before 5,000 miles and a quarter after 15,000 miles, from 8 reports that carried an odometer reading.
A part like this is normally expected to survive 95,000 miles. It is the 26th most-reported problem on this model year.
The mileage distribution
The reported range runs from 5,000 miles at the tenth percentile to 20,000 miles at the ninetieth, a spread of 18,045 miles across the middle 80% of reports.
A window that narrow is the signature of a part that fails on its own schedule rather than on how the car is driven — which is usually a design or supplier problem rather than wear and tear.
100% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 3,600 miles | 6,150 miles | 11,250 miles | 16,248 miles | 21,645 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Putting it right typically runs $900–$4,500 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 7 model years of this car. It shows up earliest on the 2019, at a median of 10,000 miles, and latest on the 2014 at 77,500 miles.
By volume the 2014 carries the most reports, with 64; the 2018 has 9. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
At 5 months 3600 miles of ownership the 4 corner air suspension went out. This also caused me to loss my electric stability control of the vehicle. While driving down the highway and switching lanes (before I know of the issue) the truck became very loose. I was driving at the speed limit and just the act of changing the lanes caused the rear end to sway a bit. I feel if this had happened to a less experienced driver they could have overreacted and caused an accident. A 16 year old would have reacted a lot different than myself a 40 year with driving experience in many different situations. The suspension going out in these vehicles is a known problem and needs to be taken care of. Dodge should own up to it. Bottom line, the 4 corner air suspension will cause serious injury or death to someone driving at highway speed when it goes out. I feel they are been enough issue with them that the air suspension should be discontinued and option giving to go back to standard suspension or warranty them for the life of the vehicle.
At 5 months 3600 miles of ownership the 4 corner air suspension went out. This also caused me to loss my electric stability control of the vehicle. While driving down the highway and switching lanes (before I know of the issue) the truck became very loose. I was driving at the speed limit and just the act of changing the lanes caused the rear end to sway a bit. I feel if this had happened to a less experienced driver they could have overreacted and caused an accident. A 16 year old would have reacted a lot different than myself a 40 year with driving experience in many different situations. The suspension going out in these vehicles is a known problem and needs to be taken care of. Dodge should own up to it. Bottom line, the 4 corner air suspension will cause serious injury or death to someone driving at highway speed when it goes out. I feel they are been enough issue with them that the air suspension should be discontinued and option giving to go back to standard suspension or warranty them for the life of the vehicle.
Also reported on the 2018 RAM 1500
Infotainment screen failure
Other engine problem
Other fuel system problem
Other electrical problem
Fuel pump failure
Other powertrain problem
How far this goes
Complaints are voluntary, so 9 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does air suspension failure happen on the 2018 RAM 1500?
Across 8 owner reports that included an odometer reading, half were filed by 10,000 miles. A quarter were filed before 5,000 miles and a quarter after 15,000 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is air suspension failure on the 2018 RAM 1500?
9 reports have been filed with NHTSA, about 0.1 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed