Air suspension failure on the 2016 RAM 1500
1 injury 1 of the 42 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
When air suspension failure gets reported
Owners of the 2016 RAM 1500 report air suspension failure at a median of 60,000 miles. A quarter of the reports come in before 35,000 miles and a quarter after 60,000 miles, from 24 reports that carried an odometer reading.
A part like this is normally expected to survive 95,000 miles. It is the 12th most-reported problem on this model year.
The mileage distribution
The reported range runs from 25,000 miles at the tenth percentile to 70,000 miles at the ninetieth, a spread of 44,620 miles across the middle 80% of reports.
A window that narrow is the signature of a part that fails on its own schedule rather than on how the car is driven — which is usually a design or supplier problem rather than wear and tear.
25% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 25,380 miles | 35,500 miles | 58,877 miles | 61,791 miles | 70,000 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 1 an injury is mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $900–$4,500 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 7 model years of this car. It shows up earliest on the 2019, at a median of 10,000 miles, and latest on the 2014 at 77,500 miles.
By volume the 2014 carries the most reports, with 64; the 2016 has 42. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
Air ride suspension quit functioning all together dealers backed with same issue on large # of vehicles. Was informed parts to fix are backordered and can't be told if it's safe to drive in this condition or not. Was told we are very aware of problem. But not a reasonable time or fix that will prevent issue from reaccuring. Noticed problem when driving on a highways 70mph.
Air ride suspension quit functioning all together dealers backed with same issue on large # of vehicles. Was informed parts to fix are backordered and can't be told if it's safe to drive in this condition or not. Was told we are very aware of problem. But not a reasonable time or fix that will prevent issue from reaccuring. Noticed problem when driving on a highways 70mph.
Tl* the contact owns a 2016 ram 1500. While driving 75 MPH, the front end of the vehicle dropped and the rear end raised 18 inches. As a result, the vehicle was at a 45 degree angle. The contact pulled the vehicle over to the side of the road to check the vehicle. The contact restarted the vehicle and drove home. The contact stated that the failure recurred three times within the past six months. The dealer (patriot chrysler, dodge, jeep, ram, 916 s george nigh expressway, mcalester, ok 74501) informed the contact that the air suspension pump needed to be replaced. The manufacturer informed the contact to call the number on the back of the owner's manual to speak with someone about the failure. The failure mileage was 30,000.
Also reported on the 2016 RAM 1500
Other engine problem
Other steering problem
Other fuel system problem
Other powertrain problem
ABS module or sensor failure
Control module (ECM/PCM/BCM) failure
How far this goes
Complaints are voluntary, so 42 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does air suspension failure happen on the 2016 RAM 1500?
Across 24 owner reports that included an odometer reading, half were filed by 60,000 miles. A quarter were filed before 35,000 miles and a quarter after 60,000 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is air suspension failure on the 2016 RAM 1500?
42 reports have been filed with NHTSA, about 0.3 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed