Control module (ECM/PCM/BCM) failure on the 2012 Jeep Wrangler
3 crashes 3 injuries 6 of the 18 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
When control module (ecm/pcm/bcm) failure gets reported
Owners of the 2012 Jeep Wrangler report control module (ECM/PCM/BCM) failure at a median of 40,000 miles. A quarter of the reports come in before 40,000 miles and a quarter after 75,000 miles, from 13 reports that carried an odometer reading.
A part like this is normally expected to survive 92,000 miles. It is the 14th most-reported problem on this model year.
The mileage distribution
The reported range runs from 15,000 miles at the tenth percentile to 85,000 miles at the ninetieth, a spread of 72,400 miles across the middle 80% of reports.
A spread this wide points at use rather than design. Towing, climate, service history and city mileage all move a failure like this, so the median is a weak guide to any individual car.
23% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 15,000 miles | 40,000 miles | 42,000 miles | 76,000 miles | 87,400 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 3 a crash and 3 an injury are mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $700–$3,000 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 20 model years of this car. It shows up earliest on the 2021, at a median of 900 miles, and latest on the 1999 at 245,000 miles.
By volume the 2018 carries the most reports, with 38; the 2012 has 18. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
The (rhd) vehicle check engine light and traction control (skid) light come on regularly while driving straight on dry roads and when the traction control light is on it causes the vehicle to slow speed. When driving over 40 MPH, it takes a while to gain speed and if you let off gas it jerks like you are driving a standard transmission. I recently had the powertrain control module replaced costing myself over $600 and it still does the same thing. I have made a stop at a stop sign before and this jeep died and started right back. Occasionally the gascap light comes on and stays for a couple days and then goes away. Another strange thing that happens a lot is the temperature on dash is set to fahrenheit, but often I have to change it back because I will look and its showing celsius. The most recent thing that happened scared even my children. I had just took off at a 4-way intersection on highway and while gaining speed with no lights on, I reached about 40 MPH and it just jerked as hard as it could and then check engine light and traction control light come on causing us to almost get run over by the people behind us gaining speed…
The (rhd) vehicle check engine light and traction control (skid) light come on regularly while driving straight on dry roads and when the traction control light is on it causes the vehicle to slow speed. When driving over 40 MPH, it takes a while to gain speed and if you let off gas it jerks like you are driving a standard transmission. I recently had the powertrain control module replaced costing myself over $600 and it still does the same thing. I have made a stop at a stop sign before and this jeep died and started right back. Occasionally the gascap light comes on and stays for a couple days and then goes away. Another strange thing that happens a lot is the temperature on dash is set to fahrenheit, but often I have to change it back because I will look and its showing celsius. The most recent thing that happened scared even my children. I had just took off at a 4-way intersection on highway and while gaining speed with no lights on, I reached about 40 MPH and it just jerked as hard as it could and then check engine light and traction control light come on causing us to almost get run over by the people behind us gaining speed…
The (rhd) vehicle check engine light and traction control (skid) light come on regularly while driving straight on dry roads and when the traction control light is on it causes the vehicle to slow speed. When driving over 40 MPH, it takes a while to gain speed and if you let off gas it jerks like you are driving a standard transmission. I recently had the powertrain control module replaced costing myself over $600 and it still does the same thing. I have made a stop at a stop sign before and this jeep died and started right back. Occasionally the gascap light comes on and stays for a couple days and then goes away. Another strange thing that happens a lot is the temperature on dash is set to fahrenheit, but often I have to change it back because I will look and its showing celsius. The most recent thing that happened scared even my children. I had just took off at a 4-way intersection on highway and while gaining speed with no lights on, I reached about 40 MPH and it just jerked as hard as it could and then check engine light and traction control light come on causing us to almost get run over by the people behind us gaining speed…
Also reported on the 2012 Jeep Wrangler
Other powertrain problem
Other steering problem
Other engine problem
Other electrical problem
Airbag warning light or occupant sensor fault
Airbag inflator rupture
How far this goes
Complaints are voluntary, so 18 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does control module (ecm/pcm/bcm) failure happen on the 2012 Jeep Wrangler?
Across 13 owner reports that included an odometer reading, half were filed by 40,000 miles. A quarter were filed before 40,000 miles and a quarter after 75,000 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is control module (ecm/pcm/bcm) failure on the 2012 Jeep Wrangler?
18 reports have been filed with NHTSA, about 0.2 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed