2002 Hyundai Elantra: what breaks, and at what mileage

What owners report breaking

Owners have reported 48 named failure modes on the 2002 Hyundai Elantra, and the three most-reported carry 33% of everything filed, which is an unusually even spread for one model year.

Control arm, ball joint or bushing failure leads with 102 reports, about 1.4 per 1,000 vehicles and with the middle half of reports between 70k to 115,000 miles.

Airbag warning light or occupant sensor fault follows with 21 reports, usually reported between 99k to 125,000 miles.

Other brake problem follows with 21 reports, usually reported between 10k to 80,000 miles.

By system, the reports fall mostly into suspension (110), airbag (54) and brakes (37).

How bad it is when it goes

Across the named modes, 58 mention a crash, 7 a fire, 25 an injury and 2 a fatality. Those are the words owners used in their own complaints, and NHTSA does not verify them, but they are the closest thing in this data to a measure of what a failure actually did.

The average severity weight across every report on this year is 5.45, where a stalled engine or a failed airbag weighs many times more than a rattling trim panel, and a figure this high means the reports are dominated by failures with safety consequences rather than annoyances. The weighting is set out in full on the methodology page.

What the top failures cost to put right, as editorial estimates for an independent US shop rather than figures from NHTSA: control arm, ball joint or bushing failure at $400–$2,200, airbag warning light or occupant sensor fault at $300–$1,600, other brake problem at $300–$1,800 and other body or interior problem at $200–$2,000. Dealer labour, a seized bolt or a part that is no longer made can push any of these past the top of its range.

7% of the reports on this year sit in the engine, transmission, drivetrain or cooling systems — the four where a repair bill is usually four figures.

How often, against how many were built

Scaled by an estimate of how many of these cars exist, the 2002 Hyundai Elantra draws about 5.7 per 1,000 vehicles, which puts it in the 82nd percentile of complaint rates among 2002 vehicles we can rate.

That denominator is the weakest number on the page and it is fair to say so plainly. Rate per 1,000 uses a fleet-size estimate derived from recall paperwork for this exact model year. It is a lower bound.

The working figure is 75,270 vehicles. If the true number is twice that, every rate on this page is half what it says; the ranking against other 2002 vehicles, which is what the risk score uses, is far more robust than the rate itself.

Recalls on the 2002 model year

NHTSA has issued 6 recall campaigns covering the 2002 Hyundai Elantra, affecting an estimated 211,462 vehicles. A recall is a different kind of evidence from a complaint: it is the regulator and the manufacturer agreeing that something has to be fixed, and the fix is free for as long as the car exists.

The campaigns cover suspension:front:control arm, air bags:frontal:sensor/control module-inactive, fuel system, gasoline:storage and fuel system, gasoline:storage:tank assembly. Whether the work was actually done on the car in front of you is a question only the VIN can answer, and the manufacturer or NHTSA will answer it free.

Recalls also distort complaint counts. Publicity about a campaign reminds owners that complaining is possible, so reports for a recalled component often spike after the recall rather than before it.

Better and worse years of the same car

High risk for a 2002 — 174th riskiest of the 329 2002 vehicles we can rate. Because the ranking is against the same model year only, age cancels out of it.

Across the 30 model years of this car that carry enough reports to score, 1998 comes out best at 60 and 2020 worst at 82, with 2002 itself at 68.

If the model year is negotiable, 1998, 1996 and 2025 score lower than 2002 by a margin worth acting on. Same body, same engines, different luck — usually a supplier change or a mid-cycle fix, which the complaint data can show but never explain.

Within the 1996–2003 generation specifically, 1998 is the strongest year at 60 and 2001 the weakest at 69.

What to look at before buying one

The mileages below are where the first quarter of reports for each mode had already been filed, which makes them the point at which a fault is worth looking for rather than the point at which it happens: other brake problem from about 10k, airbag failed to deploy in a crash from about 15k, other speed control problem from about 16k and seat belt or retractor failure from about 25k.

On a 2002 Hyundai Elantra with more miles than that on it, the useful question to put to a seller or a mechanic is whether other brake problem has been dealt with, and if so with what parts and at whose expense. A car that has already had the repair is in a different position from one that has not.

None of this is a diagnosis. It is a list of what other owners of the same model year reported, ordered by when they reported it, which is a good place to point an inspection and a poor place to stop.

Where these figures stop being useful

431 owner reports; fleet size estimated from this year's own recall paperwork. Every count on this page is therefore a floor: it is the number of owners who went to the trouble of filing with a federal agency, which is a small and self-selected fraction of the owners who had the fault.

Of those 431 reports, 308 carried an odometer reading, so the mileages here describe 71% of the sample rather than all of it. Owners also round: readings pile up on multiples of ten thousand, which is why this site publishes "about 90,000 miles" and not "91,438".

Named failure modes come from matching phrases in the complaint text, so a badly worded complaint can land in the wrong bucket. The effect washes out across hundreds of reports and does not wash out across five.

And nothing here predicts what one car will do. These are other people's complaints, filed years apart, on cars maintained by strangers. Read the page as a map of where this model year has previously gone wrong, then have the specific car in front of you inspected.