Other body or interior problem on the 2003 Honda Pilot
8 crashes 2 fires 8 injuries 18 of the 70 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
When other body or interior problem gets reported
Owners of the 2003 Honda Pilot report other body or interior problem at a median of 107,500 miles. A quarter of the reports come in before 47,500 miles and a quarter after 142,500 miles, from 58 reports that carried an odometer reading.
A part like this is normally expected to survive 88,000 miles. It is the 2nd most-reported problem on this model year.
The mileage distribution
The reported range runs from 5,000 miles at the tenth percentile to 167,500 miles at the ninetieth, a spread of 161,359 miles across the middle 80% of reports.
A spread this wide points at use rather than design. Towing, climate, service history and city mileage all move a failure like this, so the median is a weak guide to any individual car.
21% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 4,991 miles | 48,688 miles | 107,000 miles | 143,678 miles | 166,350 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 8 a crash, 2 a fire and 8 an injury are mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $200–$2,000 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 22 model years of this car. It shows up earliest on the 2020, at a median of 5,000 miles, and latest on the 2006 at 125,000 miles.
By volume the 2004 carries the most reports, with 115; the 2003 has 70. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
While backing out of the drive way and turning the steering wheel in either direction you can hear a thumping sound, it's a constant thumping. If only the back 2 windows are rolled down, the sound of the wind passing through the car is deafening. It creates a booming that immediately affects the ear drum. *jb
The base of the driver side leather seat was severely stretched and sagged (and also with 'pointy hairs' protruding from holes on all leather seats front and rears) , and the illed-mannered honda dealer's service department manager(robertson honda in north hollywood, ca) refused to replace it under the covered original honda warranty and denied totally there is anything wrong with it although the defect is so obvious and visible.*ak
While driving my 2003 pilot at speeds over 40 MPH, opening either the rear window causes a pressure imbalance within the vehicle which unless the windows are immediately closed, causes extreme ear pain to all passengers. This situation can cause a potentially hazardous situation if the vehicle is in high speed traffic and the pressure change affects the driver. I contacted my local dealer as well as american honda and they claim that they have no record of any such complaints. *nlm
Also reported on the 2003 Honda Pilot
Other powertrain problem
Other electrical problem
Ignition switch, key fob or immobilizer failure
Other engine problem
Complete transmission failure
Airbag warning light or occupant sensor fault
How far this goes
Complaints are voluntary, so 70 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does other body or interior problem happen on the 2003 Honda Pilot?
Across 58 owner reports that included an odometer reading, half were filed by 107,500 miles. A quarter were filed before 47,500 miles and a quarter after 142,500 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is other body or interior problem on the 2003 Honda Pilot?
70 reports have been filed with NHTSA, about 0.4 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed