Differential or transfer case failure on the 2002 Honda CR-V
Only 4 reports for this mode came with an odometer reading, which is too few for percentiles to mean anything. The page is here because someone linked to it; treat the figures as anecdotes, and see the full report for this year instead.
When differential or transfer case failure gets reported
There are 4 reports of differential or transfer case failure on the 2002 Honda CR-V, 4 with a mileage attached. That is too few to place the failure on the odometer with any confidence.
A part like this is normally expected to survive 110,000 miles. It is the 33rd most-reported problem on this model year.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| — | — | 300 miles | — | — |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Putting it right typically runs $900–$4,200 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 13 model years of this car. It shows up earliest on the 2015, at a median of 100 miles, and latest on the 2009 at 195,000 miles.
By volume the 2007 carries the most reports, with 19; the 2002 has 4. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
Whining noise while car is decelerating. Occurs at approximately 45 MPH and continues until stop. Mechanic stated it was rear differential--fluid was drained and flushed and replaced without a change in noise. Honda wants to try new tires before they'll change the differential. Car is a 2002 honda crv ex 4WD. *jb
Repeated mechanical failures of the 2002 honda crv that I bought brand new have been occurring since august of 2002. The car was bought in july of 2002. The odor from the inside cabin filter first occurred in august. The fuse to the warning devise that would alert the driver to lights being left on, etc. Went out within 3-4 months. Then major items which had to be replaced: differential, 2004(though still under warranty, honda refused to replace it for 2 years), neck of fuel tank broke, 2006, air conditioning system, 2007, driver-side window fell off track because the plastic clamp cracked, 2008, catalytic converter, 2009, o2 sensor, 2009, driver's seat unstable since 2003, SRS slowly went out beginning with intermittent warnings about side door air bag being turned off beginning in 2003 which dealerships ignored as just an occurence from something or someone bumping against the closed door from the inside. Finally in 2008, when the light came on to stay, I was told that it was a failure of the sensor motor__now my problem to again pay for a major repair. *tr
Repeated mechanical failures of the 2002 honda crv that I bought brand new have been occurring since august of 2002. The car was bought in july of 2002. The odor from the inside cabin filter first occurred in august. The fuse to the warning devise that would alert the driver to lights being left on, etc. Went out within 3-4 months. Then major items which had to be replaced: differential, 2004(though still under warranty, honda refused to replace it for 2 years), neck of fuel tank broke, 2006, air conditioning system, 2007, driver-side window fell off track because the plastic clamp cracked, 2008, catalytic converter, 2009, o2 sensor, 2009, driver's seat unstable since 2003, SRS slowly went out beginning with intermittent warnings about side door air bag being turned off beginning in 2003 which dealerships ignored as just an occurence from something or someone bumping against the closed door from the inside. Finally in 2008, when the light came on to stay, I was told that it was a failure of the sensor motor__now my problem to again pay for a major repair. *tr
Also reported on the 2002 Honda CR-V
Other electrical problem
Other body or interior problem
Headlight failure or clouding
Airbag warning light or occupant sensor fault
Air conditioning failure
Other engine problem
How far this goes
This page is kept out of search results because 4 reports is not enough to publish percentiles from. It stays reachable because somebody looking at this exact car would rather see the reports than be told there are none.
Complaints are voluntary, so 4 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does differential or transfer case failure happen on the 2002 Honda CR-V?
Across 4 owner reports that included an odometer reading, half were filed by 300 miles. A quarter were filed before — and a quarter after —. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is differential or transfer case failure on the 2002 Honda CR-V?
4 reports have been filed with NHTSA, about 0.0 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed