Other fuel system problem on the 2014 Ford Fusion
1 injury 1 of the 38 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
When other fuel system problem gets reported
Owners of the 2014 Ford Fusion report other fuel system problem at a median of 60,000 miles. A quarter of the reports come in before 40,000 miles and a quarter after 85,000 miles, from 21 reports that carried an odometer reading.
A part like this is normally expected to survive 90,000 miles. It is the 12th most-reported problem on this model year.
The mileage distribution
The reported range runs from 25,000 miles at the tenth percentile to 100,000 miles at the ninetieth, a spread of 73,000 miles across the middle 80% of reports.
When the reports scatter this far, the mileage is telling you about how these cars were driven more than about the part itself.
19% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 27,000 miles | 40,000 miles | 62,028 miles | 84,500 miles | 100,000 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 1 an injury is mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $300–$2,200 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 15 model years of this car. It shows up earliest on the 2016, at a median of 20,000 miles, and latest on the 2009 at 120,000 miles.
By volume the 2010 carries the most reports, with 499; the 2014 has 38. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
Tl* the contact owns a 2014 ford fusion. The contact stated that fuel was smelled while in the cabin. The vehicle was taken to the dealer where the failure could not be diagnosed. The vehicle was not repaired. The manufacturer was contacted about the failure. The failure mileage was 5,700.
First I would like to state that this vehicle has a 6 speed manual transmission. I have had acceleration/ deceleration issues since I took delivery of the vehicle in january 2014, the issues are intermittent and happen at various RPM and various speeds. Ive had the vehicle at the dealership 3 times for the same issue they have told me 3 times that there is nothing wrong with the vehicle. The problems are as follows....when shifting gears the accelerator will occasionally stick and hold that higher RPM for 5 or 6 seconds before decelerating, this happens approx. 50% of the time while shifting. The dealer tells me that this is supposed to happen this way. My response is... If it is supposed to perform this way then why doesn't it perform this way all the time rather than 50% of the time? The second acceleration/ deceleration issue is....the car will randomly accelerate to 5500- 6000 RPM, this has happened while driving 40 MPH in 6th gear it has also happened while shifting between gears. When this happens it will maintain that high RPM for 5 or 6 seconds then decelerate. On one occasion I was driving in traffic at approx. 15 MPH my…
Wether the car is cold or warm, everytime I drive, I get a hardshift between 2nd and 3rd gear. Also when I make a stop and try to accelerate, the car jerks from on the 1st gear. When I'm going on a downhill and let go of the gas pedal and slowly start braking, the would go from 2,000 RPM to 5,000 RPM while I have my foot on the brake. When I go to any gas station I can't leave the pump on auto because it would stop pumping, so I have to do it manually, in order to get a full tank.
Also reported on the 2014 Ford Fusion
Other steering problem
Other powertrain problem
Other engine problem
Other electrical problem
Other body or interior problem
Other brake problem
How far this goes
Complaints are voluntary, so 38 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does other fuel system problem happen on the 2014 Ford Fusion?
Across 21 owner reports that included an odometer reading, half were filed by 60,000 miles. A quarter were filed before 40,000 miles and a quarter after 85,000 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is other fuel system problem on the 2014 Ford Fusion?
38 reports have been filed with NHTSA, about 0.3 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed