Other steering problem on the 2006 Ford Expedition
When other steering problem gets reported
Owners of the 2006 Ford Expedition report other steering problem at a median of 130,000 miles. A quarter of the reports come in before 90,000 miles and a quarter after 135,000 miles, from 9 reports that carried an odometer reading.
A part like this is normally expected to survive 95,000 miles. It is the 11th most-reported problem on this model year.
The mileage distribution
The reported range runs from 85,000 miles at the tenth percentile to 140,000 miles at the ninetieth, a spread of 55,143 miles across the middle 80% of reports.
Reports bunched into a band this tight usually mean the component has a life of its own: it goes at roughly the same mileage regardless of who owns it.
0% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 83,257 miles | 90,000 miles | 130,000 miles | 133,237 miles | 138,400 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Putting it right typically runs $350–$2,400 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 18 model years of this car. It shows up earliest on the 2018, at a median of 500 miles, and latest on the 1997 at 190,000 miles.
By volume the 1997 carries the most reports, with 36; the 2006 has 10. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
I was driving around 46mph, and in the middle of driving, my truck cut off for around 5 seconds. I almost got by the truck behind me. My truck kicked back on by itself, all why I was driving. I was so terrified the truck behind almost rear ended me. *tr
As I was driving my expedition, the truck suddenly shut completely off and I had to power steering and then in the message center it showed "engine failsafe mode". I had to put my flashers on and coast to a stop in the lane I was in and come to a complete stop before I could restart my truck. I was unable to switch lanes or move to a safer location because I had no power steering. I had the same thing happen in march of 2009 when I was going 60 on the interstate in the middle lane and lost all power and had to coast to a stop in that lane with my flashers on hoping everyone around me would see I was having car trouble. I had 3 of my kids in the truck with me. In 2009 I took it into the ford dealership and they said it was the throttle body and replaced it which cost me $536.00. In 2009 it happened 5 times before it was fixed. I took the truck in today and they said again its the throttle body and because it's been 5 years the other one is no longer under warranty. So now I'm getting a new throttle body put in. I emailed ford corporate and was basically told that there is no current recall nor plans for one so there's nothing they…
Driving in town on four lane at 45 MPH. Fail safe light appeared and engine cut off and lost power steering. Almost rear ended as there was no place to pull off the road! Engine was restarted and did not occur again while returning home. *tr
Also reported on the 2006 Ford Expedition
Other engine problem
Other speed control problem
Other electrical problem
Airbag failed to deploy in a crash
Other fuel system problem
Other wheel or tire problem
How far this goes
Complaints are voluntary, so 10 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does other steering problem happen on the 2006 Ford Expedition?
Across 9 owner reports that included an odometer reading, half were filed by 130,000 miles. A quarter were filed before 90,000 miles and a quarter after 135,000 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is other steering problem on the 2006 Ford Expedition?
10 reports have been filed with NHTSA, about 0.7 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed