Fuel pump failure on the 2011 Dodge Challenger
Only 6 reports for this mode came with an odometer reading, which is too few for percentiles to mean anything. The page is here because someone linked to it; treat the figures as anecdotes, and see the full report for this year instead.
When fuel pump failure gets reported
There are 6 reports of fuel pump failure on the 2011 Dodge Challenger, 6 with a mileage attached. That is too few to place the failure on the odometer with any confidence.
A part like this is normally expected to survive 85,000 miles. It is the 8th most-reported problem on this model year.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| — | — | 56,000 miles | — | — |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Putting it right typically runs $600–$2,600 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 3 model years of this car. It shows up earliest on the 2014, at a median of 20,000 miles, and latest on the 2010 at 140,000 miles.
By volume the 2010 carries the most reports, with 6; the 2011 has 6. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
In early october 2014 I started smelling gas fumes inside my vehicle. I took the vehicle to a local repair shop. It was determined that my fuel tank had a factory defect where the fuel pump locking tabs were molded into the tank. The leak was around the seam where attached. This is directly under the rear passenger seat on top of the fuel tank where it would have been impossible to have been hit by anything. The tank was leaking fuel on to the exhaust system at the rear of the vehicle. We were very lucky that there was no fire. I approached dodge on more than 4 occasions to recover the cost of repairs which were $1,736.05. I have been refused each time. They are aware that the tank is defective as I have sent documentation and pictures to show them. I have asked for the name of the vender who made the tank and have been refused. This is a defect in manufacturing! The tank is available for inspection. I need help to recover my cost for someone's faulty product. I have owned automobiles for 48 years and have never had to replace a fuel tank until now. *tr
Tl* the contact owns a 2011 dodge challenger. While refueling the vehicle, the contact noticed an odor of fuel. The contact stated that the vehicle was taken to an independent mechanic who stated that there was a fracture at the top of the fuel tank on the rear passenger side of the vehicle. The contact stated that the fracture resulted in fuel leakage at the fuel pump. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 53,000.
Fuel leak by rear passenger tire. Leaks when car is parked and off. Pressure from heat outside or engine running. Dodge dealer pushed appt. Out 2 weeks. Took vehicle to own mechanic and it was found to be leaking from secondary fuel pump on the top of it.and fuel leaked in transit and constantly in driveway.
Also reported on the 2011 Dodge Challenger
Alternator or charging system failure
Other electrical problem
No-start or intermittent start failure
Other engine problem
Airbag warning light or occupant sensor fault
Airbag inflator rupture
How far this goes
This page is kept out of search results because 6 reports is not enough to publish percentiles from. It stays reachable because somebody looking at this exact car would rather see the reports than be told there are none.
Complaints are voluntary, so 6 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does fuel pump failure happen on the 2011 Dodge Challenger?
Across 6 owner reports that included an odometer reading, half were filed by 55,000 miles. A quarter were filed before — and a quarter after —. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is fuel pump failure on the 2011 Dodge Challenger?
6 reports have been filed with NHTSA, about 0.1 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed