Other electrical problem on the 2013 Chevrolet Volt
1 fire 1 injury 2 of the 38 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
When other electrical problem gets reported
Owners of the 2013 Chevrolet Volt report other electrical problem at a median of 67,500 miles. A quarter of the reports come in before 15,000 miles and a quarter after 82,500 miles, from 25 reports that carried an odometer reading.
A part like this is normally expected to survive 85,000 miles. It is the 2nd most-reported problem on this model year.
The mileage distribution
The reported range runs from 7,500 miles at the tenth percentile to 120,000 miles at the ninetieth, a spread of 113,573 miles across the middle 80% of reports.
A spread this wide points at use rather than design. Towing, climate, service history and city mileage all move a failure like this, so the median is a weak guide to any individual car.
36% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 6,960 miles | 14,238 miles | 67,000 miles | 83,000 miles | 120,533 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 1 a fire and 1 an injury are mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $250–$2,000 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 9 model years of this car. It shows up earliest on the 2018, at a median of 30,000 miles, and latest on the 2012 at 80,000 miles.
By volume the 2017 carries the most reports, with 177; the 2013 has 38. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
Car gas engine started, (engine running due to temp). Ran for just a few seconds, then shut down and went into "service mode" - killing both the gas engine and electric motor - without touching any buttons on dash. *tr
Tl* the contact owns a 2013 chevrolet volt. The contact stated that he erroneously depressed the drive mode button and all the electrical power failed. The vehicle was not taken to a dealer or independent mechanic. The manufacture was notified about the failure. The failure mileage was 7,500 and current mileage was 7,900.
The car's electrical / software issues caused (1) all of the windows to roll down in unison (in for repair 3 times to fix this one), (2) caused the car to not recognize that it was in "park", thus not shutting off, and (3) caused the car to lose power without touching any of the buttons on the console (I.e. The "drive" button or the "power" button). The latest incident occurred last friday (august 1, 2014) when the car just lost power while I was driving at 65 MPH on I-85 north at around 4:00pm. I had to get over from 4 lanes of traffic with no power at all in the car and luckily did so without incident. Onstar's diagnostics showed that the electrical system, braking system, engine, and other parts of the car showed the car needed immediate attention. I put the car in park and while still with onstar the dashboard lit up and the power button lit up too. I hit the power button and drove straight to the rick hendrick chevy dealership in duluth. When I went to pick the car up later saturday morning, I was told that there's nothing they car do because they can't recreate the problem. They have reflashed various ecus, but at the end of…
Also reported on the 2013 Chevrolet Volt
Airbag warning light or occupant sensor fault
Other fuel system problem
Other engine problem
Other body or interior problem
Other powertrain problem
Software fault or failed update
How far this goes
Complaints are voluntary, so 38 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does other electrical problem happen on the 2013 Chevrolet Volt?
Across 25 owner reports that included an odometer reading, half were filed by 67,500 miles. A quarter were filed before 15,000 miles and a quarter after 82,500 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is other electrical problem on the 2013 Chevrolet Volt?
38 reports have been filed with NHTSA, about 4.5 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed