Parking brake failure on the 2002 Chevrolet Suburban
When parking brake failure gets reported
Owners of the 2002 Chevrolet Suburban report parking brake failure at a median of 45,000 miles. A quarter of the reports come in before 25,000 miles and a quarter after 85,000 miles, from 16 reports that carried an odometer reading.
A part like this is normally expected to survive 88,000 miles. It is the 5th most-reported problem on this model year.
The mileage distribution
The reported range runs from 10,000 miles at the tenth percentile to 160,000 miles at the ninetieth, a spread of 154,252 miles across the middle 80% of reports.
A spread this wide points at use rather than design. Towing, climate, service history and city mileage all move a failure like this, so the median is a weak guide to any individual car.
44% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 7,586 miles | 25,250 miles | 43,950 miles | 83,750 miles | 161,838 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Putting it right typically runs $250–$1,300 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 7 model years of this car. It shows up earliest on the 2001, at a median of 32,500 miles, and latest on the 2005 at 110,000 miles.
By volume the 2001 carries the most reports, with 53; the 2002 has 18. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
Defective parking brakes on 2002 chevrolet suburban. *mr the engineers had not found a way to repair the problem properly. The parking brake would refuse to release at the wheels. This was an intermittent problem. *sc *jb
Failed inspection. The emergency brake was not engaging. Dealership said the back of the rear rotors had rusted out, causing the emergency brake to rust also. Had to replace both rotors and both e-brakes. Only have 27,000 miles on the car. Had just been in for a check-up before coming off warranty. Rotors and e-brakes should not need to be replace with low milage. Have spoken to four other people that have had the same problem.*ak
Dt: 2002 chevy sububran 1500ls. The parking brake is ineffective and has been since purchased the vehicle. Bought this used, but about a week later after purchase. Did take to a dealer from where it was purchased. The dealer thought that the brake was examined, and that the parking brake was okay, and should hold a vehicle on a slope. Over the last few months have decided the parking brake was a problem. There was a slope in driveway, tested, and found that it did not work. Did not take back to dealer, but owner felt it was a design defect. *ak
Also reported on the 2002 Chevrolet Suburban
ABS module or sensor failure
Loss of braking
Other wheel or tire problem
Fuel pump failure
Other brake problem
Brake line, hose or caliper failure
How far this goes
Complaints are voluntary, so 18 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does parking brake failure happen on the 2002 Chevrolet Suburban?
Across 16 owner reports that included an odometer reading, half were filed by 45,000 miles. A quarter were filed before 25,000 miles and a quarter after 85,000 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is parking brake failure on the 2002 Chevrolet Suburban?
18 reports have been filed with NHTSA, about 0.4 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed