Other brake problem on the 2009 Chevrolet Malibu
3 crashes 3 injuries 2 deaths 8 of the 71 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
When other brake problem gets reported
Owners of the 2009 Chevrolet Malibu report other brake problem at a median of 75,000 miles. A quarter of the reports come in before 52,500 miles and a quarter after 120,000 miles, from 50 reports that carried an odometer reading.
A part like this is normally expected to survive 88,000 miles. It is the 10th most-reported problem on this model year.
The mileage distribution
The reported range runs from 27,500 miles at the tenth percentile to 137,500 miles at the ninetieth, a spread of 110,173 miles across the middle 80% of reports.
A spread this wide points at use rather than design. Towing, climate, service history and city mileage all move a failure like this, so the median is a weak guide to any individual car.
14% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 26,797 miles | 52,000 miles | 76,000 miles | 119,500 miles | 136,970 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 3 a crash, 3 an injury and 2 a fatality are mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $300–$1,800 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 25 model years of this car. It shows up earliest on the 1997, at a median of 10,000 miles, and latest on the 2005 at 110,000 miles.
By volume the 2000 carries the most reports, with 117; the 2009 has 71. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
Tl*the contact owns a 2009 chevrolet malibu. While the vehicle was at an authorized dealership for routine maintenance, the contact was informed that the slides and calipers were rusted and bending. The brakes were repaired. The failure and current mileages were 15,972.
Tl* the contact owns a 2009 chevrolet impala. The contact was driving approximately 45 MPH and upon engaging the brake there was vibration within the brake pedal and steering wheel. The vehicle was taken to an authorized dealer three different times for the identical failure. The first repair consisted of resurfacing the front rotors and eventually both rotors were replaced. In addition, both front brake pads were replaced at a different time. The contact was advised by an independent mechanic that both rear brake pads and rotors would need to be replaced. The vehicle had not been repaired. The manufacturer was not made aware of the repeated defect. The approximate failure mileage was 3,000. The VIN was unavailable.
While driving at 68mph with the speed control engaged, the speed control turned off. I looked in the rear view mirror and saw break lights on. I checked the mat to verify that it was not pressing the pedal. I then depressed the pedal, the car slowed and the break lights turned off. Now the brake lights are always on when the pedal is not pressed, and they turn off after pressing the pedal. This causes other drivers to not be aware that I am stopping. *tr
Also reported on the 2009 Chevrolet Malibu
Other steering problem
Other electrical problem
Other driver assistance problem
Cruise control failure
Loss of power steering
Other body or interior problem
How far this goes
Complaints are voluntary, so 71 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does other brake problem happen on the 2009 Chevrolet Malibu?
Across 50 owner reports that included an odometer reading, half were filed by 75,000 miles. A quarter were filed before 52,500 miles and a quarter after 120,000 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is other brake problem on the 2009 Chevrolet Malibu?
71 reports have been filed with NHTSA, about 1.0 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed