Cruise control failure on the 2006 Chevrolet Malibu
1 crash 1 of the 30 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
When cruise control failure gets reported
Owners of the 2006 Chevrolet Malibu report cruise control failure at a median of 60,000 miles. A quarter of the reports come in before 52,500 miles and a quarter after 70,000 miles, from 28 reports that carried an odometer reading.
A part like this is normally expected to survive 72,000 miles. It is the 11th most-reported problem on this model year.
The mileage distribution
The reported range runs from 50,000 miles at the tenth percentile to 97,500 miles at the ninetieth, a spread of 49,100 miles across the middle 80% of reports.
A window that narrow is the signature of a part that fails on its own schedule rather than on how the car is driven — which is usually a design or supplier problem rather than wear and tear.
7% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 49,100 miles | 52,035 miles | 61,000 miles | 70,000 miles | 98,200 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 1 a crash is mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $200–$1,400 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 21 model years of this car. It shows up earliest on the 2014, at a median of 10,000 miles, and latest on the 2001 at 105,000 miles.
By volume the 2010 carries the most reports, with 174; the 2006 has 30. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
Dt*: the contact stated the cruise control would not hold the vehicle at the set speed while traveling down hill. The dealer was alerted. Updated 10/4/2006 - the vehicle has accelerated 5-15 miles per hour over the set speed. *nm
Tl*the contact owns a 2006 chevrolet malibu. While driving 50 MPH, she attempted to engage the brakes and disengage the cruise control; however, the vehicle accelerated. The vehicle began spinning out of control on two occasions. The vehicle no longer made contact with the ground, hit a wall, crossed 3 lanes and was facing in the opposite direction. The engine size is unknown. The current and failure mileage were 10500.
I just found out last night that my 2006 chevy malibu ltz brake lights illuminate without pressing the brake pedal and when I do press the pedal it goes out. This would cause anyone following my vehicle not to see that I am braking and could cause a crash. Also my cruise control and my cigarette lighter went out. I am not sure if they are all connected somehow but the brakes are definitely a concern. I will say that my car does have a salvaged title but I don't know if that would cause the safety issue. I have owned the car for 4 months and they have worked until now. I have an appointment to get it fixed and am not driving it till than. *tr
Also reported on the 2006 Chevrolet Malibu
Other steering problem
Loss of power steering
Steering column or shaft failure
Other electrical problem
Fuel gauge or level sensor failure
Steering rack, gear or tie rod failure
How far this goes
Complaints are voluntary, so 30 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does cruise control failure happen on the 2006 Chevrolet Malibu?
Across 28 owner reports that included an odometer reading, half were filed by 60,000 miles. A quarter were filed before 52,500 miles and a quarter after 70,000 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is cruise control failure on the 2006 Chevrolet Malibu?
30 reports have been filed with NHTSA, about 0.4 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed