Fuel tank, filler or EVAP failure on the 2013 Chevrolet Express
Only 1 report for this mode came with an odometer reading, which is too few for percentiles to mean anything. The page is here because someone linked to it; treat the figures as anecdotes, and see the full report for this year instead.
When fuel tank, filler or evap failure gets reported
There are 1 report of fuel tank, filler or EVAP failure on the 2013 Chevrolet Express, 1 with a mileage attached. That is too few to place the failure on the odometer with any confidence.
A part like this is normally expected to survive 88,000 miles. It is the 10th most-reported problem on this model year.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| — | — | 1,800 miles | — | — |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Putting it right typically runs $250–$1,800 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure, every year of the Chevrolet Express
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
This is a c class rv by thor motor coach. The coach serial number is [xxx]. The vehicle would not take fuel. I bought it to two chevrolet dealers who would not look at it because it had a motorhome body. One dealer hooked it up to a fault finder and found there was a fuel venting problem. They said it looked like the motor coach manufacturer had changed the fuel venting system and moved the tank. I finally was serviced, under warranty, by an rv dealer in tulsa oklahoma. They told me the fuel tank had been moved which caused a kink in the fuel filler hose to the tank. They told me this was solved by cutting a section of the fuel filler hose to make it shorter and eliminating the kink. My concern is in a rollover accident will fuel now leak? This is a medium duty chevrolet chassis so I don't really know if the same standards apply as do cars re. Fuel cutoff with rollover accidents or if I should report this to another agency? Thank you. Information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6). *tr
Also reported on the 2013 Chevrolet Express
Other engine problem
No-start or intermittent start failure
Other electrical problem
Other brake problem
Transmission slipping
Airbag failed to deploy in a crash
How far this goes
This page is kept out of search results because 1 report is not enough to publish percentiles from. It stays reachable because somebody looking at this exact car would rather see the reports than be told there are none.
Complaints are voluntary, so 1 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does fuel tank, filler or evap failure happen on the 2013 Chevrolet Express?
Across 1 owner reports that included an odometer reading, half were filed by 1,800 miles. A quarter were filed before — and a quarter after —. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is fuel tank, filler or evap failure on the 2013 Chevrolet Express?
1 reports have been filed with NHTSA, about 0.1 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed