Other steering problem on the 2006 Chevrolet Cobalt
43 crashes 2 fires 18 injuries 2 deaths 65 of the 852 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
When other steering problem gets reported
Owners of the 2006 Chevrolet Cobalt report other steering problem at a median of 62,000 miles. A quarter of the reports come in before 45,000 miles and a quarter after 85,000 miles, from 734 reports that carried an odometer reading.
A part like this is normally expected to survive 95,000 miles. It is the 1st most-reported problem on this model year.
The mileage distribution
The reported range runs from 32,000 miles at the tenth percentile to 137,000 miles at the ninetieth, a spread of 105,325 miles across the middle 80% of reports.
A spread this wide points at use rather than design. Towing, climate, service history and city mileage all move a failure like this, so the median is a weak guide to any individual car.
13% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 32,000 miles | 45,000 miles | 61,576 miles | 85,000 miles | 137,325 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 43 a crash, 2 a fire, 18 an injury and 2 a fatality are mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $350–$2,400 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 6 model years of this car. It shows up earliest on the 2007, at a median of 56,000 miles, and latest on the 2008 at 71,000 miles.
By volume the 2006 is the worst of them, which makes this a problem of this specific year rather than of the model as a whole.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
I have a 2006 chevy cobalt purchased used with 28000 miles on it. All my problems started about a month after I bought the car. The steering wheel started shaking violently when driving at 50 MPH and over so I took it in to a chevy dealer and they rotated and balanced the tires and that seemed to fix that problem. About 2 weeks I was driving home and I was sitting at a red light and the car just shut off. I restarted the car and every thing was fine on the dash board, no warning lights or messages in the driver information center. I started driving again and when I press on the gas there was this loud grinding noise and it felt like the car was not shifting gears properly. So I pulled over on the side of the road and turned the car off for about 10 minutes and restarted it and it drove fine. Now at this point im just thinking that there is a malfunction in the computer. I took the car to the dealer the next day and they scanned the computer and found no errors and everything was checking out fine. About 3 weeks later I was driving on the highway and I lost complete control of steering and the power steering message in the driver…
Tl*the contact owns a 2006 chevrolet cobalt. While driving 35 MPH, the vehicle experienced electrical failure and lost power steering. The contact crashed into a ditch. A police report was filed. The dealer was unable to duplicate the failure. The current and failure mileages were 17,800. * updated 12/12/07 *bf the consumer stated electrical problem resulted in loss of gauges and also resulted in low fuel message. The consumer stated the accident resulted in $6,500 worth of damages. Updated 12/12/07 *tr
Power assist has gone out 5 times on this car. Steering the car becomes very hard and difficult. When it happens it's unexpected and could cause an accident. Called a chevy dealership service dept. He told me to check the fuse. I did, not the problem. I'm reading about so many with this same problem that there should be a recall on this. *tr
Also reported on the 2006 Chevrolet Cobalt
Fuel pump failure
Loss of power steering
Other electrical problem
Steering column or shaft failure
Ignition switch, key fob or immobilizer failure
Other fuel system problem
How far this goes
Complaints are voluntary, so 852 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does other steering problem happen on the 2006 Chevrolet Cobalt?
Across 734 owner reports that included an odometer reading, half were filed by 62,000 miles. A quarter were filed before 45,000 miles and a quarter after 85,000 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is other steering problem on the 2006 Chevrolet Cobalt?
852 reports have been filed with NHTSA, about 13 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed