Other lighting problem on the 2004 Chevrolet Aveo
1 crash 2 fires 3 of the 12 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
Only 4 reports for this mode came with an odometer reading, which is too few for percentiles to mean anything. The page is here because someone linked to it; treat the figures as anecdotes, and see the full report for this year instead.
When other lighting problem gets reported
There are 12 reports of other lighting problem on the 2004 Chevrolet Aveo, 4 with a mileage attached. That is too few to place the failure on the odometer with any confidence.
A part like this is normally expected to survive 86,000 miles. It is the 4th most-reported problem on this model year.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| — | — | 32,500 miles | — | — |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 1 a crash and 2 a fire are mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $120–$1,200 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 6 model years of this car. It shows up earliest on the 2004, at a median of 35,000 miles, and latest on the 2006 at 110,000 miles.
By volume the 2005 carries the most reports, with 32; the 2004 has 12. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
Tl* the contact owns a 2004 chevrolet aveo. The contact stated that the turning signal lights illuminated intermittently. The contact mentioned that the vehicle was exhibiting the failure specified in recall NHTSA campaign number: 14v261000 (exterior lighting).the vehicle was not taken to a dealer. The manufacturer was made aware of the failure. The failure and current mileage was 50,000. Updated 8/11/4*cn
Tl* the contact owns a 2004 chevrolet aveo. The contact stated that while driving at various speeds, the headlights flickered intermittently. The failure recurred on several occasions. The contact received a notification of NHTSA campaign number: 14v261000 (exterior lighting) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The approximate failure mileage was 15,000. The consumer stated the recall still has not been addressed. Updated 08/24/15*jb
Tl* the contact owns a 2004 chevrolet aveo. The contact stated that while driving at various speeds, the headlights flickered intermittently. The failure recurred on several occasions. The contact received a notification of NHTSA campaign number: 14v261000 (exterior lighting) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The approximate failure mileage was 15,000. The consumer stated the recall still has not been addressed. Updated 08/24/15*jb
Also reported on the 2004 Chevrolet Aveo
Timing chain, belt or tensioner failure
Other electrical problem
Seat belt or retractor failure
Other engine problem
Thermostat failure
Airbag failed to deploy in a crash
How far this goes
This page is kept out of search results because 12 reports is not enough to publish percentiles from. It stays reachable because somebody looking at this exact car would rather see the reports than be told there are none.
Complaints are voluntary, so 12 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does other lighting problem happen on the 2004 Chevrolet Aveo?
Across 4 owner reports that included an odometer reading, half were filed by 35,000 miles. A quarter were filed before — and a quarter after —. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is other lighting problem on the 2004 Chevrolet Aveo?
12 reports have been filed with NHTSA, about 0.6 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed