2011 BMW 3 Series: what breaks, and at what mileage
What breaks on the 2011 BMW 3 Series
Only 1 defect report has been filed with NHTSA about the 2011 BMW 3 Series, which is too few to compute mileage percentiles or a risk score. The report reported other engine problem.
When each failure gets reported
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
Every reported failure mode
| Failure mode | System | Reports | With reading | 25th | Median | 75th | Per 1,000 | Typical repair | Severity |
|---|---|---|---|---|---|---|---|---|---|
| Other engine problem | engine | 1 | 0 | — | — | — | 0.0 | $300–$4,000 | High |
Rate per 1,000 uses a fleet-size estimate derived from recall paperwork for this exact model year. It is a lower bound. Repair costs are typical independent-shop ranges for the failure, not figures from these reports.
Recalls on the 2011 model year
NHTSA has issued 3 recall campaigns covering the 2011 BMW 3 Series, affecting an estimated 39,954 vehicles. A recall is a different kind of evidence from a complaint: it is the regulator and the manufacturer agreeing that something has to be fixed, and the fix is free for as long as the car exists.
The campaigns cover engine and engine cooling:engine, engine and engine cooling:exhaust system:emission control:cr and engine and engine cooling:cooling system:fan. Whether the work was actually done on the car in front of you is a question only the VIN can answer, and the manufacturer or NHTSA will answer it free.
Recalls also distort complaint counts. Publicity about a campaign reminds owners that complaining is possible, so reports for a recalled component often spike after the recall rather than before it.
ENGINE AND ENGINE COOLING:ENGINE
157,796 vehicles 2023-10-20- Defect
- BMW of North America, LLC (BMW) is recalling certain 2010-2012 1 Series Coupe, 1 Series Convertible, 3 Series Sedan, 3 Series Convertible, 2010-2011 3 Series Sportswagon, 3 Series Coupe, 5 Series Sedan, X3 xDrive 28i, X3 xDrive 30i, X5 xDrive30i, and Z4 sDrive30i vehicles. The aluminum bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and possibly break.
- Consequence
- Loose or broken VANOS unit bolts can result in an engine stall, increasing the risk of a crash.
- Remedy
- Dealers will replace the four VANOS bolts, free of charge. Interim letters notifying owners of the safety risk are expected to be mailed December 18, 2023. Owner notification letters were mailed June 19, 2024. Owners may contact BMW customer service at 1-800-525-7417.
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
917,106 vehicles 2022-03-02- Defect
- BMW of North America, LLC (BMW) is recalling certain 2008-2013 1 Series Coupe (128i); 2007-2013 3 Series Coupe (328i, 328xi, 328i xDrive); 2007-2010 X3 SAV (X3 3.0si, X3 xDrive30i); 2008-2013 1 Series Convertible (128i); 2006-2011 3 Series Sedan (325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi); 2006-2012 3 Series Wagon (328i, 328i xDrive); 2007-2013 3 Series Convertible (328i); 2006-2010 5 Series Sedan (525i, 525xi, 528i, 528xi, 530i, 530xi); 2006-2007 5 Series Wagon (530xi); 2007-2010 X5 SAV (X5 3.0si, X5 xDrive30i); 2006-2008 Z4 Coupe (Z4 3.0si); and 2006-2011 Z4…
- Consequence
- An electrical short can cause the PCV valve heater to overheat, increasing the risk of a fire while driving or, soon after driving when parked.
- Remedy
- This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Dealers will install an electrical wiring harness with fuse protection for the PCV Valve heater in potentially affected vehicles, free of charge. This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Vehicles previously repaired under the prior recalls will need to come back for the new recall remedy. The remedy is currently being developed. Interim owner notification letters informing owners of the safety risk were mailed on April 1, 2022. Owner notification letters…
ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
585 vehicles 2012-08-10- Defect
- This recall involves aftermarket parts sold by Valeo. Valeo is recalling certain engine cooling fans, part numbers 696121, 696273, and 696275, used as service replacement parts for model year 2008-2011 BMW 1-Series, 2006-2011 BMW 3-Series, 2000-2009 BMW 5-Series, 2004-2005 BMW 6-Series, and 2006-2007 BMW 7-Series vehicles. A metal-oxide semiconductor may overheat due to insufficient screwing of the semiconductor on the aluminum heat sink. This primary failure could cause adjacent components on the fan assembly motor circuit board to overheat and short.
- Consequence
- This condition could cause the fan motor to become inoperative, or cause the motor circuit board in the assembly to overheat, potentially leading to a fire in the engine compartment.
- Remedy
- Valeo will notify owners and replace the fans free of charge. The safety recall began on August 22, 2012. This recall is being conducted by Valeo, not by BMW. For further information, owners may contact Valeo at 1-888-718-2536.
Recall work is free at a franchised dealer regardless of the car's age. Check the VIN at nhtsa.gov/recalls before assuming it was done.
Every year of the BMW 3 Series
Scores compare each year against other cars of the same model year, so a low number on an older car is a real result and not an artefact of age.
Shorter is better. Years with too few reports to score are shown without a bar rather than as a zero, because no data is not good news.
What the reports on file say
The complaints recorded against the 2011 BMW 3 Series are other engine problem (1 report). With a sample this size these are anecdotes rather than a pattern, and they are shown because somebody looking at this exact car would rather see them than nothing.
Why this page is short
A model year needs about 8 reports before percentiles mean anything, and this one does not have them. Complaint volume tracks how many cars were sold and how long they have been on the road, so a thin page usually means a rare car, a new car, or a car whose owners do not file.
Other years of the same model do have enough: 2000, 2001, 2002, 2003, 2004, 2005, 2006 and 2007. The mechanical parts are often shared across those years, so their pages are the better guide to what this one is likely to do, with the caveat that a shared part is not a shared production line.
Where this comes from. Every figure above is computed from NHTSA owner complaints and recall records for this exact make, model and year. Complaints are voluntary and self-selected, so treat counts as a floor. The methodology page writes out each formula, and the same numbers are available as JSON.
What breaks at my mileage Compare with another car
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed