2008 UD Ud3300: what breaks, and at what mileage
What breaks on the 2008 UD Ud3300
No owner has filed a defect report with NHTSA about the 2008 UD Ud3300. That is not a clean bill of health — it usually means few were sold, or the year is too new for problems to have surfaced.
Recalls on the 2008 model year
NHTSA has issued 7 recall campaigns covering the 2008 UD Ud3300, affecting an estimated 455 vehicles. A recall is a different kind of evidence from a complaint: it is the regulator and the manufacturer agreeing that something has to be fixed, and the fix is free for as long as the car exists.
The campaigns cover service brakes, air, service brakes, air:supply:check valve and service brakes, air:supply:quick release valve. Whether the work was actually done on the car in front of you is a question only the VIN can answer, and the manufacturer or NHTSA will answer it free.
One caution about reading these together: a recall usually raises the complaint count for the same part, because owners who read about it go and file. The mileages stay informative; the counts get noisy.
SERVICE BRAKES, AIR
261 vehicles 2012-06-04- Defect
- Ud trucks north america (ud trucks) is recalling certain model year 2008-2010 ud 3300 trucks equipped with a dual steering system. Modifications to the vehicles may have resulted in loss of isolation between the primary and secondary air brake systems. Thus, these vehicles fail to comply with the requirements of federal motor vehicle safety standard number 121, air brake systems. modifications to the vehicles may have resulted in loss of isolation between the primary and secondary air brake systems.
- Consequence
- If the vehicle experiences an air leak in either the primary or the secondary system, the vehicle may experience a total loss of brakes, increasing the risk of a vehicle crash.
- Remedy
- Ud trucks will notify owners and will correct the air brake system of the affected vehicles. The recall began on july 12, 2012. Owners may contact ud trucks at 1-336-393-2233.
SERVICE BRAKES, AIR:SUPPLY:CHECK VALVE
1,004 vehicles 2010-01-08- Defect
- Nissan diesel is recalling certain model year 1999-2010 ud3300 vehicles. These vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 121, "air brake systems." these vehicles have insufficient air tank reserve capacity and may result in insufficient air supply to properly operate the brakes during repetitive brake applications.
- Consequence
- This may result in reduced braking performance which could result in a vehicle crash without prior warning to the vehicle operator.
- Remedy
- The air reservoir tank's volume will be increased to meet fmvss 121 requirements. Owners will be asked to bring their vehicles to a dealer to have the remedy performed free of charge. The safety recall for owners of 2008 through 2010 ud3300 vehicles began on august 20, 2010. Notification to owners of the 1999 through 2007 ud3300 vehicles is expected to begin at the end of january 2011 . Owners may contact nissan diesel at 972-756-5500.
SERVICE BRAKES, AIR:SUPPLY:QUICK RELEASE VALVE
1,004 vehicles 2010-01-01- Defect
- Nissan diesel is recalling certain model year 1999-2010 ud3300 vehicles. These vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 121, "air brake systems." the brake actuation and release timing of the air brake system on these vehicles may not perform correctly.
- Consequence
- Operation of a vehicle with incorrect air brake apply/release timing may result in reduced braking performance without warning to the vehicle operator, which could result in a vehicle crash.
- Remedy
- The air brake line will be modified. Dealers will inspect and repair vehicles at no charge. The safety recall for owners of 2008 through 2010 ud3300 vehicles began on august 20, 2010. Notification to owners of the 1999 through 2007 ud3300 vehicles is expected to begin at the end of january 2011. Owners may contact nissan diesel at 1-972-756-5500.
SERVICE BRAKES, AIR:SUPPLY:QUICK RELEASE VALVE
73 vehicles 2009-12-22- Defect
- Nissan diesel is recalling certain model year 2007 and 2008 ud3300 vehicles that were modified by installing dual steering controls for use as street sweepers. These vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 121, "air brake systems." brake recertification was not performed on these vehicles during modification of the dual steering system.
- Consequence
- Operation of a vehicle with incorrect air brake apply/release timing may result in reduced braking performance which could result in a vehicle crash without prior warning to the vehicle operator.
- Remedy
- Dealers will inspect and replace the necessary components free of charge. The safety recall is expected to begin on or before february 15, 2010. Owners may contact nissan diesel at 1-972-756-5500.
STEERING
94 vehicles 2009-08-27- Defect
- Nissan diesel is recalling certain model year 2007-2008 ud3300 vehicles that were modified by installing dual steering controls for use as street sweepers. The right side steering drag link may have been installed incorrectly.
- Consequence
- Incorrect installation of the right side steering drag link and/or improper adjustment of the steering stops could allow the tire to contact the right side steering drag link during a full left turn. Continued operation with the right front tire contacting the right side steering drag link may result in structural weakening and bending of the drag link. This could result in a loss of steering control and/or cause a vehicle crash without warning to the vehicle operator.
- Remedy
- Dealers will reinstall the right side steering drag link and the steering stop adjustment will be adjusted free of charge. The recall is expected to begin on or before october 12, 2009. Owners may contact nissan diesel at 972-756-5500.
SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS
10 vehicles 2009-04-06- Defect
- Nissan diesel is recalling 10 my 2008 ud3300 trucks equipped with arvin meritor 2-speed rear axle. The length of the air brake hose installed between the relay valve and quick release valve for the left rear air brake assembly is incorrect and may increase the resistance in the air supply.
- Consequence
- Incorrect length of air brake hose will increase the risk of a crash.
- Remedy
- Dealers will have the air brake hose replaced between the relay valve and the quick release valve with the correct length hose free of charge. The recall is expected to begin on or before may 4, 2009. Owners may contact nissan diesel at 972-756-5500.
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
549 vehicles 2008-11-24- Defect
- Nissan diesel is recalling 549 my 2008 ud1800, ud2000, ud2300, ud2600, and ud3300 medium duty trucks. A failure of the fuel injection pump drive coupler can occur. The bottom corner of the notched drive surface was improperly machined. With increased fuel pump pressure, the required turning torque on the drive coupler increased. The increased turning torque could crack the coupler at the bottom corner without warning under normal vehicle operation.
- Consequence
- Continued operation with a cracked drive coupler could result in the coupler becoming broken and causing the engine to stall and not restart, increasing the risk of a crash.
- Remedy
- Dealers will replace the fuel injection pump drive coupler. The recall began on january 19, 2009. Owners may contact nissan diesel at 1-972-756-5500.
Recall work is free at a franchised dealer regardless of the car's age. Check the VIN at nhtsa.gov/recalls before assuming it was done.
Every year of the UD Ud3300
Scores compare each year against other cars of the same model year, so a low number on an older car is a real result and not an artefact of age.
Why this page is short
A model year needs about 8 reports before percentiles mean anything, and this one does not have them. Complaint volume tracks how many cars were sold and how long they have been on the road, so a thin page usually means a rare car, a new car, or a car whose owners do not file.
Where this comes from. Every figure above is computed from NHTSA owner complaints and recall records for this exact make, model and year. Complaints are voluntary and self-selected, so treat counts as a floor. The methodology page writes out each formula, and the same numbers are available as JSON.
What breaks at my mileage Compare with another car
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed