Unclassified problem on the 2006 Toyota Rav4
4 crashes 2 fires 2 injuries 1 death 9 of the 54 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
Only 34 reports for this mode came with an odometer reading, which is too few for percentiles to mean anything. The page is here because someone linked to it; treat the figures as anecdotes, and see the full report for this year instead.
When unclassified problem gets reported
Owners of the 2006 Toyota Rav4 report unclassified problem at a median of 85,000 miles. A quarter of the reports come in before 62,500 miles and a quarter after 112,500 miles, from 34 reports that carried an odometer reading.
It is the 65th most-reported problem on this model year.
The mileage distribution
The reported range runs from 52,500 miles at the tenth percentile to 160,000 miles at the ninetieth, a spread of 106,545 miles across the middle 80% of reports.
When the reports scatter this far, the mileage is telling you about how these cars were driven more than about the part itself.
6% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 52,749 miles | 62,750 miles | 85,000 miles | 113,350 miles | 159,294 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 4 a crash, 2 a fire, 2 an injury and 1 a fatality are mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
The same failure on other years
The same failure is reported on 26 model years of this car. It shows up earliest on the 2018, at a median of 5,000 miles, and latest on the 1998 at 160,000 miles.
By volume the 2019 carries the most reports, with 149; the 2006 has 54. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
When using the dryer in a car wash the hard spare tire cover was blown off the spare tire and bashed against the vehicle and then the ground severely scratching it and cracking it. Had it no completely come off at that point it is probable that it would have flown off into the from of any following vehicle had I been traveling down a busy road potentially causing an accident. These items should "never" come of under normal use conditions. This is a serious potential accident source as well as a potential source of a law suit against the owner operator of the vehicle. In addition it is hard and can cause windshield damage to any following vehicles and should never come off when properly attached. *nm
Tl*the contact owns a 2006 toyota rav4. While driving 45 MPH, the driver struck a concrete post and none of the air bags deployed. The weather was rainy, windy, and very cold. The driver suffered congestive heart failure and died. The vehicle has been repaired, but the contact does not want to drive the vehicle and does not believe that it is safe to drive. The dealer stated that the vehicle has major failures and should not be driven. A police report was filed. The contact has pictures. The powertrain was unknown. The current and failure mileages were 41,000.
I was heading through an intersection and struck an oncoming vehicle, which failed to yield to me. I struck him in the front passenger side section of a ford ranger. The vehicle has not been repaired yet but is waiting for the other insurance company. *tr
Also reported on the 2006 Toyota Rav4
Steering rack, gear or tie rod failure
Other steering problem
Steering column or shaft failure
Excessive oil consumption
Other engine problem
Other speed control problem
How far this goes
This page is kept out of search results because 54 reports is not enough to publish percentiles from. It stays reachable because somebody looking at this exact car would rather see the reports than be told there are none.
Complaints are voluntary, so 54 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does unclassified problem happen on the 2006 Toyota Rav4?
Across 34 owner reports that included an odometer reading, half were filed by 85,000 miles. A quarter were filed before 62,500 miles and a quarter after 112,500 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is unclassified problem on the 2006 Toyota Rav4?
54 reports have been filed with NHTSA, about 0.5 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed