Other wheel or tire problem on the 2001 Toyota Prius
3 crashes 3 injuries 6 of the 28 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
When other wheel or tire problem gets reported
Owners of the 2001 Toyota Prius report other wheel or tire problem at a median of 40,000 miles. A quarter of the reports come in before 30,000 miles and a quarter after 65,000 miles, from 10 reports that carried an odometer reading.
A part like this is normally expected to survive 60,000 miles. It is the 1st most-reported problem on this model year.
The mileage distribution
The reported range runs from 25,000 miles at the tenth percentile to 80,000 miles at the ninetieth, a spread of 55,488 miles across the middle 80% of reports.
Reports bunched into a band this tight usually mean the component has a life of its own: it goes at roughly the same mileage regardless of who owns it.
50% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 25,040 miles | 27,500 miles | 41,487 miles | 66,272 miles | 80,528 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 3 a crash and 3 an injury are mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $200–$1,500 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 14 model years of this car. It shows up earliest on the 2017, at a median of 5,000 miles, and latest on the 2011 at 45,000 miles.
By volume the 2001 is the worst of them, which makes this a problem of this specific year rather than of the model as a whole.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
The consumer experienced a flat tire. The consumer noticed the tire was worn badly on the inside. The manufacturer offered a supplemental tire warranty, in which the consumer did qualify, due to the fact the tires weren't rotated. Scc
The tires on our 2001 prius continually fail after about 15,000 miles. We have had state inspections fail because of tread wear, refused service at bridgestone dealers because of tread wear. With less than 50k miles we are working on the third set of tires. We check pressure and rotate our tires regularly. Since toyota claims there are no replacements and no tread wear warranties, we think the car should no longer be allowed on the us market. *nlm
6/2001 prius; mileage ~20,000; bridgestone potenza 175/65/r14rx original tires; while driving approximately 40 MPH on surface streets, rear right passenger tread separated from the tire. Dealer recommended going to tire vendor for warrantee replacement. Plan to pursue issue with toyota.*ak
Also reported on the 2001 Toyota Prius
Other steering problem
Steering rack, gear or tie rod failure
Other electrical problem
Other speed control problem
Control module (ECM/PCM/BCM) failure
Fuel tank, filler or EVAP failure
How far this goes
Complaints are voluntary, so 28 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does other wheel or tire problem happen on the 2001 Toyota Prius?
Across 10 owner reports that included an odometer reading, half were filed by 40,000 miles. A quarter were filed before 30,000 miles and a quarter after 65,000 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is other wheel or tire problem on the 2001 Toyota Prius?
28 reports have been filed with NHTSA, about 1.6 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed