2000 Thomas Mvp EF: what breaks, and at what mileage
What breaks on the 2000 Thomas Mvp EF
No owner has filed a defect report with NHTSA about the 2000 Thomas Mvp EF. That is not a clean bill of health — it usually means few were sold, or the year is too new for problems to have surfaced.
Recalls on the 2000 model year
NHTSA has issued 11 recall campaigns covering the 2000 Thomas Mvp EF, affecting an estimated 3,031 vehicles. A recall is a different kind of evidence from a complaint: it is the regulator and the manufacturer agreeing that something has to be fixed, and the fix is free for as long as the car exists.
The campaigns cover seat belts, fuel system, diesel and electrical system:alternator/generator/regulator. Whether the work was actually done on the car in front of you is a question only the VIN can answer, and the manufacturer or NHTSA will answer it free.
Recalls also distort complaint counts. Publicity about a campaign reminds owners that complaining is possible, so reports for a recalled component often spike after the recall rather than before it.
SEAT BELTS
11,265 vehicles 2007-03-27- Defect
- Certain my 1994 through 2002 thomas built minotour, fs-65, mvp-ef, er, and hdx-ef school buses manufactured between january 23, 1994, and april 15, 2002. The seat belt may chafe on the edge of a metal bracket and wear prematurely.
- Consequence
- In the event of a vehicle crash, the seat occupant may not be properly restrained, possibly resulting in personal injury.
- Remedy
- Thomas built will notify owners and replace any chafed seat belts and replace or modify the retainer strip to prevent any further chafing. The recall began on february 8, 2008. Owners may contact thomas built at 336-889-4871 or contact freightliner at 800-547-0712.
FUEL SYSTEM, DIESEL
16,000 vehicles 2005-04-27- Defect
- Certain 1998-2003 my freightliner fs-65 school bus chassis and mb-45, mb-55, and xb shuttle bus chassis, and thomas built bus: mvp-er and mvp-ef school bus and non-school bus models equipped with cummins isb diesel engines and equipped with federal-mogal 12 and 24 volt fuel lift pumps. The fuel pump could fail to transfer fuel appropriately creating an engine stall condition.
- Consequence
- Should the engine stall while the vehicle is in use, a possible vehicle crash could occur.
- Remedy
- Cummins will notify the customers of freightliner and thomas built and replace the fuel lift pump free of charge. Owners may contact cummins at 1-800-diesels.
ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
461 vehicles 2003-06-02- Defect
- On certain thomas school buses, the alternator cable can pinch between the air conditioning compressor and engine block.
- Consequence
- This can result in damage to wire insulation and potentially cause a short circuit.
- Remedy
- Dealers will re-route the cable. Owner notification began july 28, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner/thomas built at
SEAT BELTS
2,371 vehicles 2002-10-31- Defect
- On certain school or transit buses with passenger seat belts with retractors, the cover halves for the retractable portion of the belt can separate completely and release the seat belt connector. If this occurs, one of the load bearing pins in the connector could separate from the connector and render the seat belt unusable. In the event of a crash, the seat occupant would not be properly restrained resulting in an injury. The seat belt supplier, amsafe, will provide a snap on "over-cover" to owners to prevent the seat belt cover from separating.
- Consequence
- If this occurs, one of the load bearing pins in the connector could separate from the connector and render the seat belt unusable. In the event of a crash, the seat occupant would not be properly restrained resulting in an injury.
- Remedy
- Dealers will provide a plastic outer cover that snaps over the existing cover on units in the field and will replace broken seat belts free of charge. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 336-841-5924 or amsafe at 574-266-8330.
WHEELS:LUGS/NUTS/BOLTS/STUDS
15 vehicles 2002-08-06- Defect
- On certain school and transit buses, the wheel lug nut may not tighten completely.
- Consequence
- The wheel could loosen increasing the risk of loss of control of the vehicle.
- Remedy
- Dealers will install new wheel studs. Owner notification began february 28, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 336-889-4871.
STRUCTURE:BODY
57 vehicles 2001-12-12- Defect
- Vehicle description: certain school buses fail to conform to the requirements of federal motor vehicle safety standard no. 217, "bus emergency exits and window retention and release." a third roof hatch must be added to meet the standard requirements. Only vehicles located in the state of washington are involved.
- Consequence
- In the event of a crash, the bus occupant may not be able to exit the bus quickly.
- Remedy
- Dealers will install a third roof hatch. Owner notification began may 1, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 336-889-4871.
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
129 vehicles 2001-06-26- Defect
- Vehicle description: school and transit buses equipped with safety belt assemblies produced by am-safe. On some seat belts, the buckle and connector may unlatch during a collision.
- Consequence
- Serious injury or death could occur if the vehicle occupant is not properly restrained.
- Remedy
- Am-safe notified thomas built's customers to return their vehicle to an authorized dealer to have the seat belts repaired free of charge. Owner notification began september 21, 2000. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 1-336-889-4871.
STEERING:LINKAGES
557 vehicles 2000-12-29- Defect
- Vehicle description: school and transit buses equipped with air brakes and a trw steering gear. The pinch bolt on the pitman arm contacts the exhaust port on the air brake treadle valve during steering maneuvers.
- Consequence
- This could result in increased steering effort or an over-steer condition.
- Remedy
- Dealers will add a spacer under the brake valve to provide sufficient clearance.
SEATS
6,500 vehicles 2000-11-03- Defect
- Vehicle description: certain school buses and transit buses equipped with national seating's series 93b-sb driver seat. A bracket attaching the gas spring shock to the height adjuster of the seat can deform and break. This bracket is located at the top of the height adjuster.
- Consequence
- If the bracket is not replaced after deforming, and is allowed to break, its breaking will result in a sudden drop of the driver's seat, increasing the risk of loss of control of the vehicle and a crash.
- Remedy
- Dealers will replace the seat base and add reinforcement to the seat assembly
SERVICE BRAKES, AIR:ANTILOCK
35,405 vehicles 2000-08-07- Defect
- Vehicle description: heavy duty trucks and school bus chassis built with bendix air ABS with an ec-17 1030r electronic control unit (ecu), there have been reports of unwanted ABS activation at low speeds caused by 1) chafed ABS wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal.
- Consequence
- This condition could cause the ABS ecu to exhaust the air at the air brake modulators for one or more of the wheels. This could result in extended braking distances and a possible crash.
- Remedy
- Dealers will replace the ABS ecu.
SERVICE BRAKES, AIR:ANTILOCK
4,780 vehicles 2000-08-07- Defect
- Vehicle description: school bus chassis and emergency vehicles built with bendix air ABS with an ec-17 1030r electronic control unit (ecu), there have been reports of unwanted ABS activation at low speeds caused by 1) chafed ABS wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal.
- Consequence
- This condition could cause the ABS ecu to exhaust the air at the air brake modulators for one or more of the wheels. This could result in extended braking distances and a possible crash.
- Remedy
- Dealers will replace the ABS ecu.
Recall work is free at a franchised dealer regardless of the car's age. Check the VIN at nhtsa.gov/recalls before assuming it was done.
Every year of the Thomas Mvp EF
Scores compare each year against other cars of the same model year, so a low number on an older car is a real result and not an artefact of age.
Why this page is short
A model year needs about 8 reports before percentiles mean anything, and this one does not have them. Complaint volume tracks how many cars were sold and how long they have been on the road, so a thin page usually means a rare car, a new car, or a car whose owners do not file.
Where this comes from. Every figure above is computed from NHTSA owner complaints and recall records for this exact make, model and year. Complaints are voluntary and self-selected, so treat counts as a floor. The methodology page writes out each formula, and the same numbers are available as JSON.
What breaks at my mileage Compare with another car
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed