2004 Thomas Conventional: what breaks, and at what mileage
What breaks on the 2004 Thomas Conventional
No owner has filed a defect report with NHTSA about the 2004 Thomas Conventional. That is not a clean bill of health — it usually means few were sold, or the year is too new for problems to have surfaced.
Recalls on the 2004 model year
NHTSA has issued 2 recall campaigns covering the 2004 Thomas Conventional, affecting an estimated 813 vehicles. A recall is a different kind of evidence from a complaint: it is the regulator and the manufacturer agreeing that something has to be fixed, and the fix is free for as long as the car exists.
The campaigns cover other:school bus stop arm assembly. Whether the work was actually done on the car in front of you is a question only the VIN can answer, and the manufacturer or NHTSA will answer it free.
Recalls also distort complaint counts. Publicity about a campaign reminds owners that complaining is possible, so reports for a recalled component often spike after the recall rather than before it.
OTHER:SCHOOL BUS STOP ARM ASSEMBLY
5,954 vehicles 2005-08-03- Defect
- Certain 2002-2005 my thomas built minotour, conventional, mvp-er, er, hdx, and mvp-ef model school buses manufactured between january 8, 2002, and march 8, 2005, equipped with specialty mfg "5" series stop arms originally sold in or currently registered in states other than the following states: alaska, colorado, connecticut, delaware, idaho, illinois, indiana, iowa, kansas, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, montana, nebraska, nevada, new hampshire, new jersey, new mexico, new york, north dakota, ohio, oregon, pennsylvania, rhode…
- Consequence
- Should the stop arm not perform properly, a child or pedestrian may be endangered by passing vehicles should the motorist not stop at the correct location.
- Remedy
- For those buses operated in or near any of the states listed above, thomas built is encouraging the bus owners to obtain the replacement switch. For those buses operated in the warmer states, dealers will replace the switch upon owner request. For those customers who request the remedy, thomas built will replace the original switch with a switch pack that is not sensitive to extreme cold weather and will inspect to ensure the microswitch heater wiring is properly connected. The recall began on september 14, 2005. Owners may contact thomas built's customer support office…
OTHER:SCHOOL BUS STOP ARM ASSEMBLY
13,583 vehicles 2005-07-25- Defect
- Certain 2002-2005 my thomas built minotour, conventional, mvp-er, er, hdx, and mvp-ef model school buses manufactured between january 8, 2002, and march 8, 2005, equipped with specialty mfg "5" series stop arms originally sold in or currently registered in the following states: alaska, colorado, connecticut, delaware, idaho, illinois, indiana, iowa, kansas, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, montana, nebraska, nevada, new hampshire, new jersey, new mexico, new york, north dakota, ohio, oregon, pennsylvania, rhode island, south dakota…
- Consequence
- Should the stop arm not perform properly, a child or pedestrian may be endangered by passing vehicles should the motorist not stop at the correct location.
- Remedy
- Thomas built will notify its owners and replace the original switch with a switch pack that is not sensitive to extreme cold weather and will inspect to ensure the microswitch heater wiring is properly connected free of charge. The recall began on september 14, 2005. Owners may contact thomas built's customer support office at 336-889-4871.
Recall work is free at a franchised dealer regardless of the car's age. Check the VIN at nhtsa.gov/recalls before assuming it was done.
Every year of the Thomas Conventional
Scores compare each year against other cars of the same model year, so a low number on an older car is a real result and not an artefact of age.
Why this page is short
A model year needs about 8 reports before percentiles mean anything, and this one does not have them. Complaint volume tracks how many cars were sold and how long they have been on the road, so a thin page usually means a rare car, a new car, or a car whose owners do not file.
Where this comes from. Every figure above is computed from NHTSA owner complaints and recall records for this exact make, model and year. Complaints are voluntary and self-selected, so treat counts as a floor. The methodology page writes out each formula, and the same numbers are available as JSON.
What breaks at my mileage Compare with another car
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed