2006 Sterling Acterra: what breaks, and at what mileage
What breaks on the 2006 Sterling Acterra
Only 2 defect reports have been filed with NHTSA about the 2006 Sterling Acterra, which is too few to compute mileage percentiles or a risk score. The reports reported other speed control problem.
When each failure gets reported
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
How reports accumulate
Every report with an odometer reading, cumulative, from 0 to 200,000 miles. A curve that climbs early is a car with early problems, whatever its total.
- Line share of reports filed by that mileage
Every reported failure mode
| Failure mode | System | Reports | With reading | 25th | Median | 75th | Per 1,000 | Typical repair | Severity |
|---|---|---|---|---|---|---|---|---|---|
| Other speed control problem | adas | 2 | 2 | — | 142k | — | 1.9 | $250–$2,000 | Critical |
Rate per 1,000 uses a fleet-size estimate derived from recall paperwork for this exact model year. It is a lower bound. Repair costs are typical independent-shop ranges for the failure, not figures from these reports.
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The odometer reading is the one the owner gave.
Other speed control problem
Tl*the contact owns a 2006 sterling acterra. While backing the vehicle into the garage, the contact placed the vehicle into drive and it accelerated, but would not stop. The accelerator pedal was stuck and would not release. The contact struck two other vehicles. The entire passenger side was crushed in and sustained $1,800 worth of damage. One of the two vehicles as well as the contact's vehicle was towed. The current and failure mileages were 142,208. Updated 03/11/08. *lj
Tl*the contact owns a 2006 sterling acterra. The contact shifted into drive and, when he depressed the accelerator pedal, it became stuck. He depressed the brake pedal as hard as possible, but the vehicle would not stop. The contact stated that this occurred once before while attempting to back up. The mechanic was unable to determine the cause of the failure. The current and failure mileages were 141,000. Updated 02/15/08. *lj the consumer hit 2 other vehicles. He was unable to stop the vehicle.
Recalls on the 2006 model year
NHTSA has issued 7 recall campaigns covering the 2006 Sterling Acterra, affecting an estimated 3,813 vehicles. A recall is a different kind of evidence from a complaint: it is the regulator and the manufacturer agreeing that something has to be fixed, and the fix is free for as long as the car exists.
The campaigns cover service brakes, air:supply:reservoir/tank, engine and engine cooling:engine, fuel system, other:delivery:hoses, lines/piping, and fitting and power train:axle assembly. Whether the work was actually done on the car in front of you is a question only the VIN can answer, and the manufacturer or NHTSA will answer it free.
One caution about reading these together: a recall usually raises the complaint count for the same part, because owners who read about it go and file. The mileages stay informative; the counts get noisy.
SERVICE BRAKES, AIR:SUPPLY:RESERVOIR/TANK
741 vehicles 2019-05-14- Defect
- Daimler Trucks North America LLC (DTNA) is recalling certain 2004-2019 Freightliner 108SD, 114SD, 122SD, Cascadia, Columbia, Classic, FL80, FLD 120SD, Business Class M2, Western Star 4700, 4900, 6900, Sterling Acterra, L7500, LT7500, L8500, LT8500, L9500, and LT9500 vehicles. The vehicles may have an insufficient service brake air reservoir capacity. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems."
- Consequence
- An insufficient air reservoir volume may reduce brake effectiveness, increasing the risk of crash.
- Remedy
- DTNA will notify owners, and dealers will add air reservoir capacity to the affected vehicles. Owner letters were mailed on November 29, 2021. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-815.
ENGINE AND ENGINE COOLING:ENGINE
43 vehicles 2011-08-31- Defect
- Daimler trucks north america is recalling certain model year 2005 through 2012 freightliner m2, sterling acterra, 7500 & 8500, and thomas built hdx vehicles manufactured from june 23, 2004, through march 15, 2011, equipped with specific mbe900 epa04 and epa07 model engines. The intake air grid heater may short circuit and fail due to excessive internal temperatures.
- Consequence
- A short circuited grid heater could result in a vehicle fire and injury to vehicle occupants.
- Remedy
- Daimler trucks will notify owners, and dealers will repair the vehicles free of charge. Repairs will be performed by detroit diesel corporation authorized repair facilities. The safety recall began on september 12, 2011. Owners may contact daimler trucks toll-free at 1-800-547-0712. This recall is an expansion of a previous recall, campaign number 10v-341.
FUEL SYSTEM, OTHER:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
24,650 vehicles 2008-12-17- Defect
- Daimler trucks north america (dtna) is recalling 24,650 school and non-school buses, motor home chassis, and trucks manufactured from march 9, 2004 through august 18, 2006, equipped with epa04 certified mbe900 engines, manufactured by detroit diesel between march 1, 2004, and july 31, 2006. The high pressure fuel lines and transfer tubes may fatigue and fracture.
- Consequence
- A fractured fuel line may leak diesel fuel possibly resulting in a fire or fuel may be spilled on the road causing a slippery surface, possibly resulting in a vehicle crash.
- Remedy
- Detroit diesel will notify owners and the vehicles will be repaired with more robust lines and vibration dampers free of charge. Repairs will be performed by authorized detroit diesel distributorships. The recall began on march 9, 2009. Owners may contact detroit diesel 1-313-592-3708 or dtna toll-free at 1-800-547-0712 for more information.
POWER TRAIN:AXLE ASSEMBLY
28,764 vehicles 2008-03-25- Defect
- Daimler trucks is recalling 28,764 my 2001 through 2008 fccc b2 and fs65 school bus chassis, fccc fb65 conventional buses, and sterling acterra, freightliner fln, and business class m2 heavy trucks, built from january 26, 2000, through march 24, 2008, manufactured with arvinmeritor or axle alliance company 6,000 through 8,000 pound front axles utilizing a four piece spindle-nut set. These axle assemblies may have been produced with a thin spindle nut which may lead to incorrect end play, cone spin, excessive heat, degradation of lubrication, wear of the spindle nut and…
- Consequence
- Continued operation may lead to wheel separation and possibly a vehicle crash.
- Remedy
- Daimler trucks will notify owners and will repair the vehicles free of charge. The recall began on january 8, 2009. Owners may contact daimler trucks at 1-800-547-0712.
TRAILER HITCHES:FIFTH WHEEL ASSEMBLY
38,000 vehicles 2007-11-13- Defect
- On certain truck-tractors equipped with holland simplex se or se ii fifth wheels, the latch lever pivot bolt assembly may have been over-tightened which could distort the pivot bolt spacer sleeve. Corrosion or contaminates in the pivot may cause it to bind and prevent the fifth wheel jaw from latching securely around the trailer king pin.
- Consequence
- There is a possibility that the fifth wheel may fail to latch without the driver's knowledge. When the occurs, the driver could drive away and the trailer could become disengaged increasing the risk of a crash.
- Remedy
- Dealers will replace the pivot bolt and sleeve with a hex head shoulder bolt and washer. The recall began on january 3, 2008. Owners may contact freightliner at 1-800-547-0712.
SERVICE BRAKES, AIR:SUPPLY:CHECK VALVE
75,000 vehicles 2007-07-16- Defect
- Certain freightliner school bus chassis, heavy trucks, and thomas built school buses manufactured between july 2002 and july 3, 2007, equipped with bendix sr-7 spring brake control valves. The parker scv brass 90 degree single check valves (scv) which attach to the supply port of a bendix sr-7 spring brake modulating valve can break apart. Pieces of the parker scv can become lodged inside the sr-7 spring brake modulating valve, potentially causing either leakage out of the sr-7 valve or preventing air from properly exhausting from the sr-7 valve. Also, due to a…
- Consequence
- These conditions could either result in leakage and cause a delay in the application of the spring brake without warning or possibly lead to unintended vehicle rollaway or brake drag which could result in a vehicle crash, personal injury, or death.
- Remedy
- Freightliner will notify owners and repair the vehicles free of charge. The recall began on january 11, 2008 to freightliner, sterling, and freightliner custom chassis owners; to thomas built bus owners on february 1, 2008. Owners can contact freightliner at 1-800-547-0712.
VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
1,819 vehicles 2005-12-06- Defect
- On certain trucks equipped with visteon windshield wipers, the motor may have been produced without grease applied to the output shaft gear.
- Consequence
- After a period of continuous use on the high speed setting, lack of grease on the output shaft gear may cause the gear teeth to distort or fracture during operation resulting in the loss of wiper function. Inoperative wipers under inclement weather conditions could cause a crash due to impaired visibility.
- Remedy
- Dealers will inspect the wiper motor for the presence of grease and grease the wiper motor gears if necessary. The recall began on february 13, 2006. Owners may contact freightliner at 1-800-547-0712.
Recall work is free at a franchised dealer regardless of the car's age. Check the VIN at nhtsa.gov/recalls before assuming it was done.
Every year of the Sterling Acterra
Scores compare each year against other cars of the same model year, so a low number on an older car is a real result and not an artefact of age.
What the reports on file say
The complaints recorded against the 2006 Sterling Acterra are other speed control problem (2 reports, around 142k miles). With a sample this size these are anecdotes rather than a pattern, and they are shown because somebody looking at this exact car would rather see them than nothing.
Why this page is short
A model year needs about 8 reports before percentiles mean anything, and this one does not have them. Complaint volume tracks how many cars were sold and how long they have been on the road, so a thin page usually means a rare car, a new car, or a car whose owners do not file.
Where this comes from. Every figure above is computed from NHTSA owner complaints and recall records for this exact make, model and year. Complaints are voluntary and self-selected, so treat counts as a floor. The methodology page writes out each formula, and the same numbers are available as JSON.
What breaks at my mileage Compare with another car
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed