Steering rack, gear or tie rod failure on the 2006 Pontiac G6
8 crashes 3 injuries 11 of the 100 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
When steering rack, gear or tie rod failure gets reported
Owners of the 2006 Pontiac G6 report steering rack, gear or tie rod failure at a median of 35,000 miles. A quarter of the reports come in before 27,500 miles and a quarter after 60,000 miles, from 89 reports that carried an odometer reading.
A part like this is normally expected to survive 98,000 miles. It is the 6th most-reported problem on this model year.
The mileage distribution
The reported range runs from 15,000 miles at the tenth percentile to 105,000 miles at the ninetieth, a spread of 90,328 miles across the middle 80% of reports.
When the reports scatter this far, the mileage is telling you about how these cars were driven more than about the part itself.
44% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 14,000 miles | 27,453 miles | 36,000 miles | 60,000 miles | 104,328 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 8 a crash and 3 an injury are mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $700–$2,600 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 5 model years of this car. It shows up earliest on the 2007, at a median of 30,000 miles, and latest on the 2005 at 72,500 miles.
By volume the 2006 is the worst of them, which makes this a problem of this specific year rather than of the model as a whole.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
Dt*: the contact stated while traveling at various speeds, the dashboard warning for steering illuminated and was audible. When this occurred the steering failed . The vehicle has been towed to the dealership where the computer has been reset three times. These efforts have not repaired the problem. For the most recent incident, the steering shaft will be replaced.
2006 pontiac g6 taken to dealer for noise in front when steering. Dealer returned vehicle stating "they could find nothing." appox 2 months later vehicle was taken back for same problem only worse. Vehicle was returned with dealership stating the rack and pinion need replaced along with a right front hub (wheel baring) but the parts needed ordered. One week later dealer contacted and stated "parts were on back order." the vehicle is hard to control with these problems. Later told this is a very common problem and parts cannot be produced fast enough to correct them all. Service department stated vehicle was ok to drive. *nm
2006 pontiac g6 taken to dealer for noise in front when steering. Dealer returned vehicle stating "they could find nothing." appox 2 months later vehicle was taken back for same problem only worse. Vehicle was returned with dealership stating the rack and pinion need replaced along with a right front hub (wheel baring) but the parts needed ordered. One week later dealer contacted and stated "parts were on back order." the vehicle is hard to control with these problems. Later told this is a very common problem and parts cannot be produced fast enough to correct them all. Service department stated vehicle was ok to drive. *nm
Also reported on the 2006 Pontiac G6
Other steering problem
Loss of power steering
Cruise control failure
Steering column or shaft failure
Other electrical problem
Other brake problem
How far this goes
Complaints are voluntary, so 100 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does steering rack, gear or tie rod failure happen on the 2006 Pontiac G6?
Across 89 owner reports that included an odometer reading, half were filed by 35,000 miles. A quarter were filed before 27,500 miles and a quarter after 60,000 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is steering rack, gear or tie rod failure on the 2006 Pontiac G6?
100 reports have been filed with NHTSA, about 0.9 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed