Other fuel system problem on the 2006 Mercedes Benz E350
5 fires 1 injury 6 of the 67 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
When other fuel system problem gets reported
Owners of the 2006 Mercedes Benz E350 report other fuel system problem at a median of 90,000 miles. A quarter of the reports come in before 65,000 miles and a quarter after 115,000 miles, from 62 reports that carried an odometer reading.
A part like this is normally expected to survive 90,000 miles. It is the 1st most-reported problem on this model year.
The mileage distribution
The reported range runs from 40,000 miles at the tenth percentile to 155,000 miles at the ninetieth, a spread of 113,318 miles across the middle 80% of reports.
A spread this wide points at use rather than design. Towing, climate, service history and city mileage all move a failure like this, so the median is a weak guide to any individual car.
5% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 41,024 miles | 64,096 miles | 90,000 miles | 115,000 miles | 154,342 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 5 a fire and 1 an injury are mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $300–$2,200 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 9 model years of this car. It shows up earliest on the 2014, at a median of 5,000 miles, and latest on the 2011 at 95,000 miles.
By volume the 2007 carries the most reports, with 72; the 2006 has 67. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
Mercedes e350 2006, has bad odor of gas. I noticed after filling up gas, and parked my car in garage in the morning my whole garage had a smell of gas. I looked around underneath and every where inside outside I don't see any leak of gas. I can just smell gas fumes... I have called mercedes dealer haven't heard anything back and I research web and found so many other cars of mercedes have this problem.. I hope this can be recall and fix. *tr
On gas filled up, the entire garage smell of strong gasoline smell that can cause nausea and dizziness if garage door is not opened to allow fresh air, mechanics said there is a leak in the fuel system and similar car owners have the same issue. Smell will go away when the fuel level is below 7/8 level. I started having this problem at around 40,000 miles and currently around 48,000, I hardly use the vehicle due to the smell and safety concern. Mercedes should recall this defects for epa, safety and health concerns before any incidence and resulting class action lawsuit. *tr
Heavy gas smell inside and outside vehicle. Fuel leaking from defective elbow hose connection allowing gas to leak inside the vehicle under the back seat insulation and fuel cover; fuel traveled outside of the vehicle by way of dripping from underneath the back of the vehicle along the exhaust pipe causing strong gas fumes when parked and while driving. *tr
Also reported on the 2006 Mercedes Benz E350
Fuel leak or fuel odor
Fuel tank, filler or EVAP failure
Other engine problem
Fuel pump failure
Other brake problem
Other powertrain problem
How far this goes
Complaints are voluntary, so 67 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does other fuel system problem happen on the 2006 Mercedes Benz E350?
Across 62 owner reports that included an odometer reading, half were filed by 90,000 miles. A quarter were filed before 65,000 miles and a quarter after 115,000 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is other fuel system problem on the 2006 Mercedes Benz E350?
67 reports have been filed with NHTSA, about 14 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed