Other engine problem on the 2005 Jeep Wrangler
When other engine problem gets reported
Owners of the 2005 Jeep Wrangler report other engine problem at a median of 75,000 miles. A quarter of the reports come in before 45,000 miles and a quarter after 85,000 miles, from 18 reports that carried an odometer reading.
A part like this is normally expected to survive 95,000 miles. It is the 5th most-reported problem on this model year.
The mileage distribution
The reported range runs from 700 miles at the tenth percentile to 115,000 miles at the ninetieth, a spread of 115,380 miles across the middle 80% of reports.
When the reports scatter this far, the mileage is telling you about how these cars were driven more than about the part itself.
22% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 720 miles | 44,000 miles | 72,533 miles | 87,250 miles | 116,100 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Putting it right typically runs $300–$4,000 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 27 model years of this car. It shows up earliest on the 2004, at a median of 1,500 miles, and latest on the 2002 at 125,000 miles.
By volume the 2024 carries the most reports, with 187; the 2005 has 23. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
Vehicle has problems with drivability and safety issues with its suspension along with goodyear tires being out of round and/or manufactured with internals not correctly molded in tire.
Odi 10137688 follow up kudos to jeep for standing by their product, they are currently replacing the entire exhaust system and I am hopeful this remedies the overwhelming exhaust smell coming into the passenger compartment. Hope the paint issue goes as well. *nm
2005 rubicon-2480 miles. Engine indicator light has come on for the 8th time. Dealer checked with digital reader which identifies "small evaporative leak". First time, tightened gas cap, but dealer had turned off the indicator light with the reader. Third occurrence dealer scheduled check of exhaust and clean air system, all tested fine. Last 4 times I disconnected battery until light reset. Dealer has changed hands, and just scheduled for another check, mentioned replacing gas cap. This appears to be a nuisance issue rather than a serious defect. I wish they could fix it once and for all. I am not sure how this new dealer will support the warranty issues. Formerly they were great. *jb
Also reported on the 2005 Jeep Wrangler
Fuel tank, filler or EVAP failure
Other fuel system problem
Other steering problem
Other suspension problem
Other powertrain problem
Fuel pump failure
How far this goes
Complaints are voluntary, so 23 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does other engine problem happen on the 2005 Jeep Wrangler?
Across 18 owner reports that included an odometer reading, half were filed by 75,000 miles. A quarter were filed before 45,000 miles and a quarter after 85,000 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is other engine problem on the 2005 Jeep Wrangler?
23 reports have been filed with NHTSA, about 1.1 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed