Other suspension problem on the 2004 Jeep Wrangler
1 crash 1 injury 2 of the 50 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
When other suspension problem gets reported
Owners of the 2004 Jeep Wrangler report other suspension problem at a median of 47,500 miles. A quarter of the reports come in before 27,500 miles and a quarter after 67,500 miles, from 45 reports that carried an odometer reading.
A part like this is normally expected to survive 100,000 miles. It is the 2nd most-reported problem on this model year.
The mileage distribution
The reported range runs from 15,000 miles at the tenth percentile to 87,500 miles at the ninetieth, a spread of 73,201 miles across the middle 80% of reports.
When the reports scatter this far, the mileage is telling you about how these cars were driven more than about the part itself.
31% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 15,339 miles | 28,000 miles | 47,000 miles | 68,000 miles | 88,540 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 1 a crash and 1 an injury are mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $350–$2,000 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 27 model years of this car. It shows up earliest on the 2020, at a median of 600 miles, and latest on the 2002 at 145,000 miles.
By volume the 2018 carries the most reports, with 314; the 2004 has 50. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
Just started with power loss from show room floor,cam replaced lifters replaced breaks sticking to the point where the jeep is hard to move says it is because of rust used dayly,timing out 15 degrees front and rear dif leaking with metal shavings inside mechanic says dana problem grinding right front axel noise. *nm
First off you need to do a google search for 'death wobble'. I am not the only one with this problem. It is getting worse and I am afraid for my wife to drive the jeep. "death wobble".. The death wobble is basically when you are driving your jeep down the road and the front end starts to shake violently. It can happen at virtually any speed, though mostly above 40 MPH or so, and is a frightening experience, especially for those witnessing it for the first time. The only way to stop it is to slow down and pull over. It seems to get more and more out of control. Our jeep is a 2004 wrangler with only 17,000 miles. We have had the problem since 5,000 miles or so. Jeep needs to address this problem. *nm
Vehicle will enter into a violent wobble and shake when hitting a bump at highway speed. Violent shaking does not stop until speed is reduced to under 20 MPH. Had wheels rotated and balanced, wheels aligned. Checked all tie rods, ball joints, and linkage with no noticeable wear. Death wobble still present. *jb
Also reported on the 2004 Jeep Wrangler
Other steering problem
Seat belt or retractor failure
Other powertrain problem
Other wheel or tire problem
Differential or transfer case failure
Control arm, ball joint or bushing failure
How far this goes
Complaints are voluntary, so 50 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does other suspension problem happen on the 2004 Jeep Wrangler?
Across 45 owner reports that included an odometer reading, half were filed by 47,500 miles. A quarter were filed before 27,500 miles and a quarter after 67,500 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is other suspension problem on the 2004 Jeep Wrangler?
50 reports have been filed with NHTSA, about 172 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed