2000 Jayco Designer: what breaks, and at what mileage
What breaks on the 2000 Jayco Designer
Only 5 defect reports have been filed with NHTSA about the 2000 Jayco Designer, which is too few to compute mileage percentiles or a risk score. The reports reported other body or interior problem.
When each failure gets reported
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
How reports accumulate
Every report with an odometer reading, cumulative, from 0 to 200,000 miles. A curve that climbs early is a car with early problems, whatever its total.
- Line share of reports filed by that mileage
Every reported failure mode
| Failure mode | System | Reports | With reading | 25th | Median | 75th | Per 1,000 | Typical repair | Severity |
|---|---|---|---|---|---|---|---|---|---|
| Other body or interior problem | body | 3 | 1 | — | 27k | — | 1.2 | $200–$2,000 | Moderate |
| Tire blowout or tread separation | wheels | 1 | 0 | — | — | — | 0.4 | $200–$1,500 | Critical |
| Other wheel or tire problem | wheels | 1 | 1 | — | 2k | — | 0.4 | $200–$1,500 | High |
Rate per 1,000 uses a fleet-size estimate derived from recall paperwork for this exact model year. It is a lower bound. Repair costs are typical independent-shop ranges for the failure, not figures from these reports.
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The odometer reading is the one the owner gave.
Other body or interior problem
Weld disconnected from the frame of the trailer while driving. Manufacturer was contacted.*ak trailer was towed a total of 27000 miles at time of failure in alaska total mileage on trailer 35000 miles. *tc
Other wheel or tire problem
All the tires experienced blowouts within 3 months. The tires were taken back to the distributor who informed the consumer that they would not be able to replace the tires. Manufacturer is not able to determine the cause of the defect (goodyear tires - 225/75r15 - 2000 jayco designer trailer, DOT unknown). *ts *tt *nlm
Recalls on the 2000 model year
NHTSA has issued 5 recall campaigns covering the 2000 Jayco Designer, affecting an estimated 3,269 vehicles. A recall is a different kind of evidence from a complaint: it is the regulator and the manufacturer agreeing that something has to be fixed, and the fix is free for as long as the car exists.
The campaigns cover equipment:recreational vehicle/trailer, vehicle speed control, structure and seat belts:front:buckle assembly. Whether the work was actually done on the car in front of you is a question only the VIN can answer, and the manufacturer or NHTSA will answer it free.
Recalls also distort complaint counts. Publicity about a campaign reminds owners that complaining is possible, so reports for a recalled component often spike after the recall rather than before it.
EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
74 vehicles 2008-06-03- Defect
- Jayco is recalling 74 my 1999-2001 designer fifth wheel motor homes equipped with norcold refrigerators. A fatigue failure in the section of the cooling unit which contains the refrigerant could allow the liquid solution to slowly leak.
- Consequence
- Extended operation of a leaking cooling unit could lead to a fire from gas which might escape.
- Remedy
- Jayco is working with norcold to repair these refrigerators. Norcold will provide thermal switch kits to owners along with the necessary forms and instructions. The recall began on june 23, 2008. Owners may contact norcold at 1-800-767-9101 or jayco at 1-574-825-5861.
VEHICLE SPEED CONTROL
6,285 vehicles 2006-08-30- Defect
- On certain motor homes built on ford chassis, the speed control deactivation switch may overheat.
- Consequence
- Overheating could result in smoke or burning, and in an underhood fire.
- Remedy
- Ford is conducting this recall (please see 06v286) and will install a fused wiring harness into the speed control system free of charge. Owners may contact ford at 1-866-436-7332 or jayco at 1-800-283-8267.
STRUCTURE
12,281 vehicles 2001-08-01- Defect
- Vehicle description: travel and fifth wheel trailers. The fasteners used on the underfloor can either come loose or pull through the underfloor causing portions or all of a section of underfloor to detach from the vehicle.
- Consequence
- If this occurred, the section could fall to the pavement, potentially causing a crash for following vehicles.
- Remedy
- Dealers will add or replace fasteners. Owner notification began september 28, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact jayco at 1-219-825-5861.
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
727 vehicles 2001-04-10- Defect
- Vehicle description: certain motor homes equipped with safety belt assemblies produced by am-safe. On some seat belts, the buckle and connector may unlatch during a collision.
- Consequence
- Serious injury or death could occur if the vehicle occupant is not properly restrained.
- Remedy
- Dealers will repair the seat belts. Owner notification began october 23, 2000. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact jayco at 1-219-825-5861 or am-safe at 1-219-266-8330.
UNKNOWN OR OTHER
432 vehicles 2000-03-22- Defect
- Vehicle description: mini motor homes. Certain pleated shades failed the requirements of fmvss no. 302, "flammability of interior materials."
- Consequence
- If a fire occurred in the motor home, the pleated shades would burn at an accelerated rate, increasing the risk of personal injury.
- Remedy
- Dealers will replace the pleated shades on these motor homes.
Recall work is free at a franchised dealer regardless of the car's age. Check the VIN at nhtsa.gov/recalls before assuming it was done.
Every year of the Jayco Designer
Scores compare each year against other cars of the same model year, so a low number on an older car is a real result and not an artefact of age.
What the reports on file say
The complaints recorded against the 2000 Jayco Designer are other body or interior problem (3 reports, around 27k miles), tire blowout or tread separation (1 report) and other wheel or tire problem (1 report, around 2k miles). With a sample this size these are anecdotes rather than a pattern, and they are shown because somebody looking at this exact car would rather see them than nothing.
Why this page is short
A model year needs about 8 reports before percentiles mean anything, and this one does not have them. Complaint volume tracks how many cars were sold and how long they have been on the road, so a thin page usually means a rare car, a new car, or a car whose owners do not file.
Where this comes from. Every figure above is computed from NHTSA owner complaints and recall records for this exact make, model and year. Complaints are voluntary and self-selected, so treat counts as a floor. The methodology page writes out each formula, and the same numbers are available as JSON.
What breaks at my mileage Compare with another car
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed