Timing chain, belt or tensioner failure on the 2006 Hyundai Sonata
When timing chain, belt or tensioner failure gets reported
Owners of the 2006 Hyundai Sonata report timing chain, belt or tensioner failure at a median of 1 miles. A quarter of the reports come in before 1 miles and a quarter after 15,000 miles, from 11 reports that carried an odometer reading.
A part like this is normally expected to survive 120,000 miles. It is the 20th most-reported problem on this model year.
The mileage distribution
The reported range runs from 1 miles at the tenth percentile to 45,000 miles at the ninetieth, a spread of 45,999 miles across the middle 80% of reports.
Reports bunched into a band this tight usually mean the component has a life of its own: it goes at roughly the same mileage regardless of who owns it.
82% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 1 miles | 1 miles | 1 miles | 14,500 miles | 46,000 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Putting it right typically runs $1,200–$4,500 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
This mode is classified as critical, which means a failure can leave the car unable to stop, steer, or stay out of the way of traffic. It is weighted accordingly in the risk score.
The same failure on other years
The same failure is reported on 7 model years of this car. It shows up earliest on the 2006, at a median of 1 miles, and latest on the 2012 at 185,000 miles.
By volume the 2001 carries the most reports, with 14; the 2006 has 12. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
This complaint applies to a 2007 hyundai sonata limited (no option for 2007 was available in drop down menu) (issue 1) at or around the initial few days after taking delivery I began to notice abrupt vibration and shaking coming from the steering wheel; substantial enough to feel in the seat. Vehicle was taken back to dealership on 3 separate occasions to remedy the problem but they reported that they were unable to duplicate the problem and reported the vehicle to be in manufacturer specification. Nonetheless, dealer attempted wheel balance and radial force balance as a "good will gesture." problem is now more articulated and the issue remains unresolved. (issue 2) engine emits a rattle noise similar to lifter clatter upon start and continues throughout operation; particularly in colder weather. Timing chain tensioner was replaced and one noise was resolved but the continual nature of the lifter clatter remains. Dealership and hyundai representative reported that they were unable to duplicate the problem and the issue remains unresolved. (issue 3) fuel sloshing coming from the fuel tank. Manufacturer and dealer claims this to be…
This complaint applies to a 2007 hyundai sonata limited (no option for 2007 was available in drop down menu) (issue 1) at or around the initial few days after taking delivery I began to notice abrupt vibration and shaking coming from the steering wheel; substantial enough to feel in the seat. Vehicle was taken back to dealership on 3 separate occasions to remedy the problem but they reported that they were unable to duplicate the problem and reported the vehicle to be in manufacturer specification. Nonetheless, dealer attempted wheel balance and radial force balance as a "good will gesture." problem is now more articulated and the issue remains unresolved. (issue 2) engine emits a rattle noise similar to lifter clatter upon start and continues throughout operation; particularly in colder weather. Timing chain tensioner was replaced and one noise was resolved but the continual nature of the lifter clatter remains. Dealership and hyundai representative reported that they were unable to duplicate the problem and the issue remains unresolved. (issue 3) fuel sloshing coming from the fuel tank. Manufacturer and dealer claims this to be…
This complaint applies to a 2007 hyundai sonata limited (no option for 2007 was available in drop down menu) (issue 1) at or around the initial few days after taking delivery I began to notice abrupt vibration and shaking coming from the steering wheel; substantial enough to feel in the seat. Vehicle was taken back to dealership on 3 separate occasions to remedy the problem but they reported that they were unable to duplicate the problem and reported the vehicle to be in manufacturer specification. Nonetheless, dealer attempted wheel balance and radial force balance as a "good will gesture." problem is now more articulated and the issue remains unresolved. (issue 2) engine emits a rattle noise similar to lifter clatter upon start and continues throughout operation; particularly in colder weather. Timing chain tensioner was replaced and one noise was resolved but the continual nature of the lifter clatter remains. Dealership and hyundai representative reported that they were unable to duplicate the problem and the issue remains unresolved. (issue 3) fuel sloshing coming from the fuel tank. Manufacturer and dealer claims this to be…
Also reported on the 2006 Hyundai Sonata
Airbag warning light or occupant sensor fault
Other visibility problem
Seat belt or retractor failure
Control arm, ball joint or bushing failure
Other body or interior problem
Other brake problem
How far this goes
Complaints are voluntary, so 12 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does timing chain, belt or tensioner failure happen on the 2006 Hyundai Sonata?
Across 11 owner reports that included an odometer reading, half were filed by 1 miles. A quarter were filed before 1 miles and a quarter after 15,000 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is timing chain, belt or tensioner failure on the 2006 Hyundai Sonata?
12 reports have been filed with NHTSA, about 0.1 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed