Complete engine failure or seizure on the 2016 Hyundai Santa FE
1 fire 1 of the 31 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
Only 3 reports for this mode came with an odometer reading, which is too few for percentiles to mean anything. The page is here because someone linked to it; treat the figures as anecdotes, and see the full report for this year instead.
When complete engine failure or seizure gets reported
There are 31 reports of complete engine failure or seizure on the 2016 Hyundai Santa FE, 3 with a mileage attached. That is too few to place the failure on the odometer with any confidence.
A part like this is normally expected to survive 105,000 miles. It is the 2nd most-reported problem on this model year.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| — | — | 106,000 miles | — | — |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 1 a fire is mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $4,500–$12,000 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
This mode is classified as critical, which means a failure can leave the car unable to stop, steer, or stay out of the way of traffic. It is weighted accordingly in the risk score.
The same failure on other years
The same failure is reported on 12 model years of this car. It shows up earliest on the 2020, at a median of 45,000 miles, and latest on the 2010 at 110,000 miles.
By volume the 2017 carries the most reports, with 72; the 2016 has 31. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
While driving on the interstate, I noticed a tapping noise that sounded like a flap hitting the car. I needed gas, so got off at the next exit. While exiting the interstate, the noise got louder and the car didn't want to accelerate. I pulled into the gas station. As I entered the parking spot, the car died. (it had burned oil in the past. I have had an engine cam replaced in aug/sept 2019). I checked the oil. No oil! So, I ran and bought 5 quarts of oil and put them in the engine. I started the car and it didn't want to idle, but finally did after a minute. I rolled down my window and the car noise was multiple clanging sounds. It was as loud as a bad muffler. I shut off the car and called my boyfriend. He said it sounded like my engine blew. I called mcgraths in hiawatha, iowa and had the car towed there. I am 6000 miles over my 100,000 mile warranty. I am told that hyundai won't cover this issue. However, what happened to my car sounded exactly like the problem with the hyundai 4 cylinder engine troubles that were recalled in 2018. Hyundai knew I was having engine issues in 2019, and would only replace the cam. I feel that my…
While driving on the interstate, I noticed a tapping noise that sounded like a flap hitting the car. I needed gas, so got off at the next exit. While exiting the interstate, the noise got louder and the car didn't want to accelerate. I pulled into the gas station. As I entered the parking spot, the car died. (it had burned oil in the past. I have had an engine cam replaced in aug/sept 2019). I checked the oil. No oil! So, I ran and bought 5 quarts of oil and put them in the engine. I started the car and it didn't want to idle, but finally did after a minute. I rolled down my window and the car noise was multiple clanging sounds. It was as loud as a bad muffler. I shut off the car and called my boyfriend. He said it sounded like my engine blew. I called mcgraths in hiawatha, iowa and had the car towed there. I am 6000 miles over my 100,000 mile warranty. I am told that hyundai won't cover this issue. However, what happened to my car sounded exactly like the problem with the hyundai 4 cylinder engine troubles that were recalled in 2018. Hyundai knew I was having engine issues in 2019, and would only replace the cam. I feel that my…
While driving on the interstate, I noticed a tapping noise that sounded like a flap hitting the car. I needed gas, so got off at the next exit. While exiting the interstate, the noise got louder and the car didn't want to accelerate. I pulled into the gas station. As I entered the parking spot, the car died. (it had burned oil in the past. I have had an engine cam replaced in aug/sept 2019). I checked the oil. No oil! So, I ran and bought 5 quarts of oil and put them in the engine. I started the car and it didn't want to idle, but finally did after a minute. I rolled down my window and the car noise was multiple clanging sounds. It was as loud as a bad muffler. I shut off the car and called my boyfriend. He said it sounded like my engine blew. I called mcgraths in hiawatha, iowa and had the car towed there. I am 6000 miles over my 100,000 mile warranty. I am told that hyundai won't cover this issue. However, what happened to my car sounded exactly like the problem with the hyundai 4 cylinder engine troubles that were recalled in 2018. Hyundai knew I was having engine issues in 2019, and would only replace the cam. I feel that my…
Also reported on the 2016 Hyundai Santa FE
Other engine problem
Excessive oil consumption
Other brake problem
Other powertrain problem
Engine knock or bearing noise
Airbag warning light or occupant sensor fault
How far this goes
This page is kept out of search results because 31 reports is not enough to publish percentiles from. It stays reachable because somebody looking at this exact car would rather see the reports than be told there are none.
Complaints are voluntary, so 31 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does complete engine failure or seizure happen on the 2016 Hyundai Santa FE?
Across 3 owner reports that included an odometer reading, half were filed by 105,000 miles. A quarter were filed before — and a quarter after —. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is complete engine failure or seizure on the 2016 Hyundai Santa FE?
31 reports have been filed with NHTSA, about 0.7 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed