Other engine problem on the 2001 Hyundai Santa FE
When other engine problem gets reported
Owners of the 2001 Hyundai Santa FE report other engine problem at a median of 75,000 miles. A quarter of the reports come in before 60,000 miles and a quarter after 115,000 miles, from 12 reports that carried an odometer reading.
A part like this is normally expected to survive 95,000 miles. It is the 3rd most-reported problem on this model year.
The mileage distribution
The reported range runs from 50,000 miles at the tenth percentile to 140,000 miles at the ninetieth, a spread of 90,876 miles across the middle 80% of reports.
A spread this wide points at use rather than design. Towing, climate, service history and city mileage all move a failure like this, so the median is a weak guide to any individual car.
8% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 49,200 miles | 60,383 miles | 76,112 miles | 112,969 miles | 140,076 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Putting it right typically runs $300–$4,000 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 25 model years of this car. It shows up earliest on the 2018, at a median of 15,000 miles, and latest on the 2026 at 190,000 miles.
By volume the 2017 carries the most reports, with 330; the 2001 has 25. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
On june 12th the vehicle started to rattle and proceeded to shake. The vehicle would not accelerate but instead decelerated on 695 towards towson. The vehicle was drifting at 25 MPH. I then proceeded to the nearest exit which was bel air road. I proceeded onto this exit when my vehicle shut off losing all power. At this time my dashboard lights were on. I had no power but my vehicle was still in gear and I safely stopped my vehicle in a shopping plaza. Engine failure new engine placed into my vehicle. *ak july 5th the vehicle was taken back to thompson hyundai by my father. The mileage out was 25,593. Thompson hyundai forgot to screw down the engine properly resulting in loud noises from the engine. I placed another call to thompson asking for documentation of the service rendered. I then noticed another screw which was not secure on the engine. In addition, I would be bringing the vehicle back to get the documentation and to get the steering checked. Thompson never wrote up a service slip for the screws. July 8th the vehicle broke down. The vehicle was towed into thompson again. I placed a call to thompson and spoke with gary…
On june 12th the vehicle started to rattle and proceeded to shake. The vehicle would not accelerate but instead decelerated on 695 towards towson. The vehicle was drifting at 25 MPH. I then proceeded to the nearest exit which was bel air road. I proceeded onto this exit when my vehicle shut off losing all power. At this time my dashboard lights were on. I had no power but my vehicle was still in gear and I safely stopped my vehicle in a shopping plaza. Engine failure new engine placed into my vehicle july 5th the vehicle was taken back to thompson hyundai by my father. The mileage out was 25,593. Thompson hyundai forgot to screw down the engine properly resulting in loud noises from the engine. I placed another call to thompson asking for documentation of the service rendered. I then noticed another screw which was not secure on the engine. In addition, I would be bringing the vehicle back to get the documentation and to get the steering checked. Thompson never wrote up a service slip for the screws. July 8th the vehicle broke down. The vehicle was towed into thompson again. I placed a call to thompson and spoke with gary welch…
2001 santa fe 4 cylinder car stalled,wouldn't start, had to replace crankcase position sensor, old part not available, exact same problem subject of recall campaign for 6 cylinder engine of same model car, hyundai refuses to assist. *nm
Also reported on the 2001 Hyundai Santa FE
Control arm, ball joint or bushing failure
Other suspension problem
Alternator or charging system failure
Other electrical problem
Rust or structural corrosion
Other powertrain problem
How far this goes
Complaints are voluntary, so 25 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does other engine problem happen on the 2001 Hyundai Santa FE?
Across 12 owner reports that included an odometer reading, half were filed by 75,000 miles. A quarter were filed before 60,000 miles and a quarter after 115,000 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is other engine problem on the 2001 Hyundai Santa FE?
25 reports have been filed with NHTSA, about 0.4 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed