Premature brake pad or rotor wear on the 2006 Honda Accord
Only 4 reports for this mode came with an odometer reading, which is too few for percentiles to mean anything. The page is here because someone linked to it; treat the figures as anecdotes, and see the full report for this year instead.
When premature brake pad or rotor wear gets reported
There are 7 reports of premature brake pad or rotor wear on the 2006 Honda Accord, 4 with a mileage attached. That is too few to place the failure on the odometer with any confidence.
A part like this is normally expected to survive 45,000 miles. It is the 19th most-reported problem on this model year.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| — | — | 500 miles | — | — |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Putting it right typically runs $300–$1,400 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 17 model years of this car. It shows up earliest on the 2006, at a median of 500 miles, and latest on the 1998 at 100,000 miles.
By volume the 2008 carries the most reports, with 100; the 2006 has 7. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
Dt*: the contact stated the front of the vehicle vibrates anytime the brakes are applied. The vehicle has not been seen by the dealer, but was inspected by the contact. The contact, a certified mechanic, determined the rotors were beginning to show excessive wear at only 6,812 miles. Updated 3/9/2006 - *nm
I purchased a new 2006 honda accord in march 2006 and I experienced a thumping in the brake pedal and made an appointment with the dealer and returned the vehicle where they resurfaced the rotors. I was not happy with a new vehicle having resurfaced rotors so I had the dealer make a notation on my warranty order. Within a week I was experiencing the same problem. I contacted the dealer and they resurfaced them again and I was real unhappy because when I left the dealer the problem was still there. I contacted the service manager who agreed to have the rotors changed which supposedly they did. Well I am starting to experience the same type of thumping when exiting the highway but at a lesser level at this time. I do feel however that honda may have a problem in this area and would hope they correct it soon as this is a safety issue. I have owned honda's since 1975 and have never experienced the amount of problem I have had with this honda as I have on all my other honda's combined. *jb
Brake judder : in a technical service bulletins my personal family mechanic finally found what I had been complaining about for 6 months to honda. A wiggle a shake or what ever you want to call it get this fix free....VIN#that start with 1hg or 3hg are eligible for brake pad replacement and turned rotors free. Honda knows but refuse to give the information out I had to get a copy of the report and take it to them before they fixed for free technical service bulletins. *tr
Also reported on the 2006 Honda Accord
Other steering problem
Other electrical problem
Other brake problem
Other powertrain problem
Airbag warning light or occupant sensor fault
Other body or interior problem
How far this goes
This page is kept out of search results because 7 reports is not enough to publish percentiles from. It stays reachable because somebody looking at this exact car would rather see the reports than be told there are none.
Complaints are voluntary, so 7 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does premature brake pad or rotor wear happen on the 2006 Honda Accord?
Across 4 owner reports that included an odometer reading, half were filed by 500 miles. A quarter were filed before — and a quarter after —. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is premature brake pad or rotor wear on the 2006 Honda Accord?
7 reports have been filed with NHTSA, about 0.1 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed