Other electrical problem on the 2015 Ford Fusion
1 crash 1 fire 2 of the 64 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
When other electrical problem gets reported
Owners of the 2015 Ford Fusion report other electrical problem at a median of 70,000 miles. A quarter of the reports come in before 50,000 miles and a quarter after 92,500 miles, from 35 reports that carried an odometer reading.
A part like this is normally expected to survive 85,000 miles. It is the 5th most-reported problem on this model year.
The mileage distribution
The reported range runs from 17,500 miles at the tenth percentile to 132,500 miles at the ninetieth, a spread of 114,715 miles across the middle 80% of reports.
A spread this wide points at use rather than design. Towing, climate, service history and city mileage all move a failure like this, so the median is a weak guide to any individual car.
23% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 16,600 miles | 49,750 miles | 69,000 miles | 92,310 miles | 131,315 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 1 a crash and 1 a fire are mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $250–$2,000 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 15 model years of this car. It shows up earliest on the 2020, at a median of 5,000 miles, and latest on the 2008 at 85,000 miles.
By volume the 2010 carries the most reports, with 224; the 2015 has 64. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
I was driving southbound on I-75 almost to perrysburg in the middle lane and my car completely shut off. My car was still in drive, but all the lights on my dash went black and when I pressed on the gas pedal I wasn't going anywhere. There was a truck next to me in the right hand lane, I waited for it to pass and then got over. I finally made it to the shoulder and put my car in park. I then waited a couple minutes and restarted my car.
03/2015 lost control of the breaks and had to use the parking breaks to attempt to stop me and u still hit another car. 07/09/2015 lost all control of breaks, instrument panel display turned white and the mft turned black, motor shut off. The dealer can't find the problem, they just do a computer reset and it temporarily fixes the problem but they reject me to put my child in this car!
While driving the vehicle, I went to reverse and turn around. When I shifted into reverse all electrical systems failed, brakes no longer worked, and I slowly went back until I hit a small concrete pillar. This problem has happened now multiple times, at random speeds and random times. It's never set on a specific motion or action.
Also reported on the 2015 Ford Fusion
Other engine problem
Misfire or rough idle
Other powertrain problem
Other steering problem
Other brake problem
Steering rack, gear or tie rod failure
How far this goes
Complaints are voluntary, so 64 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does other electrical problem happen on the 2015 Ford Fusion?
Across 35 owner reports that included an odometer reading, half were filed by 70,000 miles. A quarter were filed before 50,000 miles and a quarter after 92,500 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is other electrical problem on the 2015 Ford Fusion?
64 reports have been filed with NHTSA, about 0.5 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed