Other body or interior problem on the 2002 Ford F-350 SD
2 crashes 1 injury 3 of the 4 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
Only 3 reports for this mode came with an odometer reading, which is too few for percentiles to mean anything. The page is here because someone linked to it; treat the figures as anecdotes, and see the full report for this year instead.
When other body or interior problem gets reported
There are 4 reports of other body or interior problem on the 2002 Ford F-350 SD, 3 with a mileage attached. That is too few to place the failure on the odometer with any confidence.
A part like this is normally expected to survive 88,000 miles. It is the 10th most-reported problem on this model year.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| — | — | 58,347 miles | — | — |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 2 a crash and 1 an injury are mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $200–$2,000 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 13 model years of this car. It shows up earliest on the 2020, at a median of 200 miles, and latest on the 1999 at 120,000 miles.
By volume the 2017 carries the most reports, with 8; the 2002 has 4. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
We have a 2000 ford f350 vehicle that was recently in an accident and the body shop found that it had prior damage. It is iowa law that the dealer must ask the previous owner about any prior damage and when we purchased this truck from mid states ford in des moines/waukee, iowa they did not notify us of any prior damage. The prior damage make the vehicle unsafe to drive as it has the wrong cab on it and the wrong cab has been welded on, as you can see the welding marks underneath the truck, and also the seat belts have been bolted in and not drilled in, but their are many drilled holes in the bottom of the truck cab. The body shop feels that the truck is unsafe to drive as you never know when the welding could collapse. We have pictures of the previous damage along with two witnesses. We have notified mid states ford and also ford motor company with a long list of things that have happen since june 9th, 2003. Mid states ford has not contacted us since dennis contacted then on july 8th and they said they would get right back to us. Ford motor company has not called us back since our last note to them last week. We just want some…
Tl*the contact owns a 2002 ford f350 super duty. The vehicle was taken to the dealer to have a safety recall repaired. At that time, the contact was informed that the vehicle needed to have an oil change. Also, the oil pan needed to be changed because it was rusting and pitting. The cost to replace the oil pan on her diesel engine is $2,399.82. The contact stated that the rear universal had to be replaced at 27,770 miles and then had to be replaced a second time, in addition to the carrier bearings at 47,325 miles. The vehicle was under warranty the first time, but the contact paid for the repair the second time. The recall number was unknown. The current and failure mileages were 58,347. Updated 02-04-08. *kb the consumer stated replaced weatherstrip, replaced rear u joint, disc pads replace, and replaced broken console lid. Updated 02/04/08 *tr
Left front tire thread separated while traveling northbound on i75 at mile marker 311. Separation caused truck to veer left into the median guard rail at high rate of speed and continue along guard rail until stopped. 911 called which brought ems and fhp. Aaa called which brought wrecker. Driver and passenger shaken up with passenger being transported to hospital by ems for hypertension/high blood pressure. Fhp filed report, case #fhpc140ff039496. Wrecker removed truck front left wheel/tire from under guard rail and transported to impound lot. Damage to left front of truck and along left side to rear dual wheels; front bumper, front grill, broken steering rod, left fender, left wheel, left side of hood, driver's door, and rear passenger door. Unknown condition of front 4WD axle or frame. *tr
Also reported on the 2002 Ford F-350 SD
Other engine problem
Tire blowout or tread separation
Other wheel or tire problem
Other electrical problem
Other powertrain problem
Misfire or rough idle
How far this goes
This page is kept out of search results because 4 reports is not enough to publish percentiles from. It stays reachable because somebody looking at this exact car would rather see the reports than be told there are none.
Complaints are voluntary, so 4 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does other body or interior problem happen on the 2002 Ford F-350 SD?
Across 3 owner reports that included an odometer reading, half were filed by 60,000 miles. A quarter were filed before — and a quarter after —. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is other body or interior problem on the 2002 Ford F-350 SD?
4 reports have been filed with NHTSA, about 0.1 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed