Other electrical problem on the 2012 Ford F-250
3 fires 3 of the 8 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
Only 4 reports for this mode came with an odometer reading, which is too few for percentiles to mean anything. The page is here because someone linked to it; treat the figures as anecdotes, and see the full report for this year instead.
When other electrical problem gets reported
There are 8 reports of other electrical problem on the 2012 Ford F-250, 4 with a mileage attached. That is too few to place the failure on the odometer with any confidence.
A part like this is normally expected to survive 85,000 miles. It is the 10th most-reported problem on this model year.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| — | — | 73,000 miles | — | — |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 3 a fire is mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $250–$2,000 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 14 model years of this car. It shows up earliest on the 2014, at a median of 30,000 miles, and latest on the 1999 at 220,000 miles.
By volume the 2004 carries the most reports, with 22; the 2012 has 8. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
Tl* the contact owns a 2012 ford f-250. The contact stated that burning fumes were emitted into the vehicle. The contact stated that the fumes made his eyes burn and made his stomach upset. The vehicle was taken to the dealer who was unable to diagnose the failure. The manufacturer was made aware of the failure who did not offer any assistance. The vehicle was not repaired. The VIN was not available. The failure mileage was 7 and the current mileage was 108,000.
Two different problems: first I was left stranded about 2 1/2 hours away from home because of a simple egt sensor defect shut down my truck. Had to pay a tower $350 to drive my truck to dealership and they tell me it was a little sensor that left me stranded. This type thing shouldn't happen when you pay $60,000 plus for a vehicle. Now months later I have another issue that from all the blogs say is a problem most 2012 models have called the "death wobble". It is now happening at least once on every drive I make. I have had over 8 situations where I have had to slam on breaks to make the vibration stop and the car behind me almost slam into the back of my truck. Because once the wobbling starts you have to come to almost a complete stop before the wobbling will stop. My wife now refuses to drive my truck because she is scared to death to drive it. I don't even like to drive it, but it's necessary because it is the only vehicle I have to drive. I am at the point of wanting to trade it, but what kind of trade in am I going to get with this problem happening. My 2012 just has a little more than 40,000 miles, not very much when you…
Also reported on the 2012 Ford F-250
Other suspension problem
Other steering problem
Other engine problem
Control arm, ball joint or bushing failure
Other wheel or tire problem
Fuel pump failure
How far this goes
This page is kept out of search results because 8 reports is not enough to publish percentiles from. It stays reachable because somebody looking at this exact car would rather see the reports than be told there are none.
Complaints are voluntary, so 8 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does other electrical problem happen on the 2012 Ford F-250?
Across 4 owner reports that included an odometer reading, half were filed by 75,000 miles. A quarter were filed before — and a quarter after —. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is other electrical problem on the 2012 Ford F-250?
8 reports have been filed with NHTSA, about 2.5 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed